Advertisement
Quick Links
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to
Wear eye
instruction
protection
manual
1. SAFETY
Locate the log splitter in a suitable work area, keep the area clean and tidy, free from unrelated materials and ensure there is adequate
9
lighting.
Keep the log splitter clean for best performance.
9
Remove ill fitting clothing, ties, watches, rings and other loose jewellery and contain loose hair.
9
Maintain correct balance and footing, do not over-reach. Ensure the floor is not slippery and wear non-slip, protective footwear.
9
Keep children and unauthorised persons away from the work area.
9
DO NOT use the log splitter for a task it is not designed to perform.
8
DO NOT operate the log splitter if damaged.
8
DO NOT operate the log splitter when you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
DO NOT allow untrained persons to operate the log splitter.
8
DO NOT make any modifications to the log splitter.
8
DO NOT operate the log splitter in wet or damp areas or expose it to rain.
8
Store the log splitter in a safe area away from children and other people not qualified to use the log splitter.
9
Wear protective gloves. Always wear safety goggles. Everyday spectacles are not sufficient protection.
9
The log splitter must always be operated by one person only. Other people must keep a safe distance from the log splitter, especially
9
when it is in operation.
Ensure that there are no nails, screws or other foreign objects in logs to be split.
9
The end of logs should be cut square.
9
WARNING! The warnings, cautions and instructions referred to in this manual cannot cover all possible conditions and situations that
‰
may occur. It must be understood that common sense and caution are factors which cannot be built into this product, but must be
applied by the operator.
NOTE: This tool is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities or lack of
experience and knowledge, unless they have been given supervision or instruction concerning the use of the tool by a person
responsible for their safety. Children should be supervised to ensure that they do not play with the tool.
2. INTRODUCTION
Heavy-duty steel construction with adjustable foot pedal, splits firewood easily with each step on the foot pedal exerting a splitting force of up to
1.2 Tonne. Minor assembly required. Folds down for easy storage.
3. SPECIFICATION
Model no: .................................................................. LS450H
Maximum Load Pressure: ........................................ 1.2tonne
Maximum Log Diameter: ............................................ 250mm
Maximum Log Length: ................................................ 450mm
Overall Size (W x D x H): ........................370 x 835 x 520mm
4. ASSEMBLY
WARNING! the foot pedal is under tension. Before removing the safety clip, put your hand on the pedal to prevent it flying up and
‰
injuring you.
4.1.
To assemble, ensure that the adjustment screw is wound all the way in, and is touching the back of the splitter head.
4.2.
Remove the safety clip and fit the foot assembly. Refit the safety clip and hook it over the foot pedal.
4.3.
The log splitter is now ready to use.
5. OPERATION
5.1.
ADJUSTING WORKING HEIGHT
5.1.1.
Remove the safety clip and adjust the foot pedal height to at least 33cm (13 inches) by screwing the adjustment screw out (to raise the
foot pedal) and in (to lower the foot pedal.)
5.2.
SPLITTING LOGS (Refer to fig.2)
5.2.1.
Tips:
Wet or non seasoned wood is more difficult to split than dry wood because the fibres stick together.
© Jack Sealey Limited
HORIZONTAL FOOT OPERATED LOG SPLITTER
MODEL NO:
Wear safety
Wear protective
footwear
gloves
Original Language Version
LS450H
LS450H Issue:2 (H,F) 19/01/23
Advertisement
Related Manuals for Sealey LS450H
Summary of Contents for Sealey LS450H
- Page 1 LS450H MODEL NO: Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions, and properly maintained, give you years of trouble free performance. IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED.
- Page 2 Important: No Liability is accepted for incorrect use of this product. Warranty: Guarantee is 12 months from purchase date, proof of which is required for any claim. REGISTER YOUR PURCHASE HERE Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR 01284 757500 sales@sealey.co.uk www.sealey.co.uk Original Language Version ©...