Page 1 ORDER NO. ITD0509054CE High Definition Plasma Display TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK GPH8D Chassis SPECIFICATIONS Specifications Power Source (UK) 120 V AC, 50/60Hz Power Source (BK/EK) 220 - 240 V AC, 50/60 Hz Power Consumption (UK) Maximum 675 W Stand-by condition Save OFF 0.7 W, Save ON 0.5 W...
Page 2 Horizontal scanning frequency 15 - 110 kHz Vertical scanning frequency 48 - 120 Hz Connection terminals VIDEO IN / OUT (BNC) 1.0 Vp-p (75-ohm or high impedance) S VIDEO IN (MINI DIN 4PIN) Y: 1 Vp-p (75-ohm), C: 0.286 Vp-p (75-ohm) AUDIO IN (RCA PIN JACK ×...
Page 3 1. Applicable signals 2. Safety Precautions...
Page 4 2.1. General Guidelines 1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, see to it that all the protective devices such as insulation barriers, insulation papers shields are properly installed.
Page 5: Prevention Of Electrostatic Discharge (Esd) To Electrostatically Sensitive (Es) Devices
4. Check each exposed metallic part, and measure the voltage at each point. 5. Reverse the AC plug in the AC outlet and repeat each of the above measurements. 6. The potential at any point should not exceed 0.75 volts RMS. A leakage current tester (Simpson Model 229 or equivalent) may be used to make the hot checks, leakage current must not exceed 1/2 milliamp.
Page 6: About Lead Free Solder (Pbf)
6. Do not remove a replacement ES device from its protective package until immediately before you are ready to install it. (Most replacement ES devices are packaged with leads electrically shorted together by conductive foam, aluminum foil or comparable conductive material). 7.
Page 7: Pcb Structure Sheet Of Gph8D Chassis
± 10 °C). - Pb free solder will tend to splash when heated too high (about 1100 °F or 600 °C). If you must use Pb solder, please completely remove all of the Pb free solder on the pins or solder area before applying Pb solder. If this is not practical, be sure to heat the Pb free solder until it melts, before applying Pb solder.
Page 8: Service Hint
LED (stand-by / Power on) & Remote receiver Fan control Line filter, Power supply PC / RS-232C BNC Composite Video BNC Component Video Remarks 1: Recommend PCB's for initial service for GPH8D chassis. 2: For TH-65PHD8BK/EK/UK 3: For TH-65PHD8UK 6. Service Hint...
Page 9: Remove The Screws
Note: Extension cable kit for Slot Board is supplied as service fixtures and tools. (Part No. TZSC0704) 7. Disassembly - To remove P.C.B., wait for 1 minute after power was off for discharge from electrolysis capacitors. marks indicate screw positions. 7.1.
Page 10 7.2. Removal of the HA-Board and the HB-Board 7.2.1. TH-65PHD8UK - Removal of the HB-Board 1. Remove the 4 screws (A) of the HB Terminal Block and then remove the HB Terminal Block. 2. Remove the 4 screws (B). 3. Remove the 2 screws (C) and then remove the HB-Board. - Removal of the HA-Board 1.
Page 11 7.2.2. TH-65PHD8EK/BK - Removal of the HB-Board 1. Remove the 4 screws (G) of the HB Terminal Block and then remove the HB Terminal Block. 2. Remove the 4 screws (H). 3. Remove the 2 screws (J) and then remove the HB-Board. 7.3.
Page 12 7.4. Removal of the J-Board 1. Remove the HA Terminal Block and the HB Terminal Block. (Reference to Removal of the HA-Board and the HB-Board) 2. Remove the Slot Block. (Reference to Removal of the Slot Block) 3. Remove the 8 screws and then remove the J-Board. 7.5.
Page 13 7.6. Removal of the PB-Board 1. Disconnect the couplers(PB30, PB31, PB32, PB33, PB34, PB35, PB37, PB38). 2. Remove the 3 scewqs and then remove the PB-Board Block. 3. Remove the 1 screw and then remove the PB-Board. 7.7. Removal of the D-Board 1.
Page 14 7.8. Removal of the P-Board 1. Disconnect the couplers(P2, P5, P9, P10, P11, P12, P23, P25, P30). 2. Remove the 8 screws and then remove the P-Board. 7.8.1. Removal of the P(P-1)-Board 1. Disconnect the couplers(CN01, CN02, CN03). 2. Remove the 5 screws.(Top view) 3.
Page 15 4. Remove the P(P-1)-Board from the 6 molding props. 7.8.2. Removal of the P(P-2)-Board 1. Disconnect the couplers(CN05, CN06, CN08). 2. Remove the 5 screws.(Top view) 3. Remove the 8 screws.(Bottom view)
Page 16 4. Remove the P(P-2)-Board from the 6 molding props. Note: - When assembling the P(P-1)-Board and the P(P-2)-Board, the position of each hole of the insulation sheets(A, B, C, D) is set to the position of each hole of the P(P-1)-Board and the P(P-2)-Board and then assemble them.
Page 17 7.9. Removal of the SU-Board and the SD-Board 1. Disconnect the couplers(SC45, SC46). 2. Remove the each 4 screws. 3. Slide the SU-Board and the SD-Board to the left (arrow1). 4. Disconnect the coupler(SU45). 5. Remove the flexible cables from the couplers(SU1, SU2, SU3, SU4) and then remove the SU-Board.
Page 18 7.10. Removal of the SC-Board 1. Disconnect the couplers(PB31, PB32). 2. Remove the each 4 screws and then remove the Fan Block (C). 3. Slide the SU-Board and the SD-Board to the left. (Refarence to Removal of the SU-Board and the SD-Board) 4.
Page 19 the SS3-Board. 7.12. Removal of the SS-Board 1. Disconnect the couplers(PB35, PB38). 2. Remove the 4 screws and then remove the Fan Block (D). 3. Disconnect the couplers(SS11, SS12, SS23, SS27, SS34, SS35, SS42, SS44). 4. Remove the flexible cables from the couplers(SS53, SS54, SS55, SS56).
Page 20 7.13. Removal of the H3-Board (L, R) 1. Remove the each 2 screws and then remove the Speaker Terminal Blocks (L, R). 2. Disconnect the coupler(H37). 3. Remove the 3 screws (K) and then remove the H3-Board. 7.14. Removal of the C1, C2, C3, C4, C5 and the C6-Board 1.
Page 21 7.14.1. Removal of the C1-Board 1. Remove the flexible cable from the coupler(C10). 2. Disconnect the coupler(C11). 3. Remove the 8 screws and then remove the flexible cables from the couplers(CA1, CA2, CA3, CA4). 4. Remove the 6 screws and then remove the C1-Board. 7.14.2.
Page 22 7.14.3. Removal of the C3-Board 1. Remove the flexible cable from the coupler(C31). 2. Disconnect the couplers(C33, C35). 3. Remove the 8 screws and then remove the flexible cables from the couplers(CA8, CA9, CA10, CA11). 4. Remove the 6 screws and then remove the C3-Board. 7.14.4.
Page 23 7.14.5. Removal of the C5-Board 1. Remove the flexible cables from the couplers(C50, C51, C54, C55). 2. Disconnect the couplers(C52, C53). 3. Remove the 6 screws and then remove the flexible cables from the couplers(CB5, CB6, CB7). 4. Remove the 6 screws and then remove the C5-Board. 7.14.6.
Page 24: Removal Of The Fan
7.15. Removal of the Fan 1. Disconnect the couplers(PB31, PB32, PB33, PB34, PB35, PB37, PB38). 2. Remove the each 4 screws and then remove the Fan Blocks(A, B, C, D). 7.15.1. Removal of the Fan (Middle/R) 1. Remove the 4 screws and then remove the Fan (Middle/R). 7.15.2.
Page 25: Removal Of The Escutcheon
1. Remove the 4 screws and then remove the Fan (Big). 2. Remove the 4 screws and then remove the Fan (Middle/L). 7.15.3. Removal of the Fan (SC/SS) on the SC-Board side 1. Remove the each 4 screws and then remove the Fans (SC/SS). 7.15.4.
Page 26 3. Pull the bottom of the Escutcheon in the direction of the arrow1 and lift up the Escutcheon in the direction of the arrow2 and then remove the Escutcheon. 4. Remove the 2 screws(L) and then remove the S1-Board Block and then Power Button Block.
Page 27 7.17. Removal of the S1-Board and the V1-Board 1. Remove the Escutcheon. (Refernce to Removal of Escutcheon) 2. Remove the 2 screws (N) and then remove the S1-Board Block. 3. Remove the 1 screw (P) and then remove the S1-Board. 4.
Page 28 7.18. Removal of the Plasma Panel 1. Disconnect the couplers(PB31, PB32, PB33, PB34, PB35, PB37, PB38). 2. Remove the each 4 screws and then remove the Fan Blocks(A, B, C, D). 3. Remove the each 2 screws and then remove the Reinforcement Angles (L, R).
Page 29 6. Disconnect the couplers(D20, D25, PB30). 7. Remove the flexible cables from the couplers(D31, D32, D33, D34). 8. Remove the 7 screws and then remove the PB-Board Block and D- Board. 9. Disconnect the couplers(P2, P9, P11, P12, P23). 10. Remove the 8 screws and then remove the P-Board. 11.
Page 30 14. Remove the flexible cables from the couplers(SU1, SU2, SU3, SU4, SD1, SD2, SD3, SD4) and then remove the SU-Board and the SD-Board. 15. Remove the 10 screws and then remove the SC-Board. 16. Remove the SS2-Board and the SS3-Board. (Reference to Removal of the SS2-Board and the SS3-Board).
Page 31 20. Remove the 22 screws. 21. Remove the flexible cables from the couplers(CA1, CA2, CA3, CA4, CA5, CA6, CA7, CA8, CA9, CA10, CA11). 22. Disconnect the couplers(C11, C33). 23. Remove the flexible cables from the couplers(C10, C21, C24, C25). 24. Remove the each 6 screws and then remove the C1-Board, the C2- Board and the C3-Board.
Page 32 27. Disconnect the couplers(C43, C61). 28. Remove the flexible cables from the couplers(C41, C50, C54, C55). 29. Remove the each 6 screws and then remove the C4-Board, the C5- Board and the C6-Board. 30. Remove the each 2 screws and then remove the Shield Plate and the Angle.
Page 33: Location Of Lead Wiring
33. Remove the each 3 screws and then remove the Cable Holders (A, B) and the flexible cables. 34. Remove the 13 screws of the Escutcheon. 35. Lift up the bottom of the Plasma Panel in the direction of the arrow1 and pull the Plasma Panel in the direction of the arrow2 and then remove the Plasma Panel.
Page 35: Adjustment Procedure
9. Adjustment Procedure 9.1. Driver Set-up 9.1.1. Item / Preparation 1. Input a white signal of the RGB signal generator. 2. Set the picture adjustment items as follows. - Picture menu : Standard - Color temperature : Normal - Picture : 25 - Aspect : Full 9.1.2.
Page 36: Initialization Pulse Adjust
Adjust driver section voltages referring the panel data on the panel data label. Caution 1. First perform Vsus voltage adjustment. 2. Confirmation of Vscn voltage should be performed after confirmation of Vad voltage adjustment. When Vad = -85V, Voltage of Vscn is 35V ± 4V. 9.2.
Page 37: Printed Circuit Board) Remove
9.3. P.C.B. (Printed Circuit Board) Remove 9.3.1. Caution 1. To remove P.C.B., wait 1 minute after power was off for discharge from electrolysis capacitors. 9.3.2. Quick adjustment after P.C.B. Remove P.C.B. Name Test Point Voltage Volume Remarks P Board Vsus TPVSUS 182V ±...
Page 38: Service Mode
9.5. Test Point Location 10. Service mode 10.1. CAT (computer Aided Test) mode...
Page 39 To exit the CAT mode, access the ID mode and switch off the main power. 10.1.1. IIC mode Select the IIC mode by Up/Down button on the remote control at the front page of CAT mode and then press the Action button on the remote control. Subject and item are mentioned on “IIC mode structure”.
Page 40: Iic Mode Structure (Following Items Value Is Sample Data.)
Micom software version (IC9702), this version can be upgrade by 1. replace of new version IC 2. Loading the new version software from loader tool, TZSC07036. Memory data change To exit the CD mode, press the R button on the remote control. 10.1.3.
Page 41: Troubleshooting Guide
11. Alignment 11.1. PC / RGB panel white balance 11.2. HD / 525ip / 625ip panel white balance 12. Trouble shooting guide 12.1. Self Check 12.1.1. Display Indication 1. Self-check is used to automatically check the bus line controlled circuit of the Plasma display. 2.
Page 42 pressing the OFF-TIMER button on the remote control, and the screen will show :- If the CCU ports have been checked and found to be incorrect Or not located then " - - " will appear in place of " OK " “...
Page 43 3. Remarks Above Fan function is operated during the fans are installed. 12.2. No Power [First check point] 1. No lit. 2. Green is lit then turns red blinking a few seconds later. 3. Only red is lit. 1. No lit. 12.3.
Page 44: Local Screen Failure
12.4. Local screen failure Plasma display may have local area failure on the screen. Fig - 1 is the possible defect P.C.B. for each local area. Fig - 1...
Page 45: Option Setting
13. Option Setting...
Page 46 Option Menu for GPH8D series GPH8D chassis series have special function and operation setting facility called Option Menu. This Option Menu is useful for special function required customers. This should be set at the installation stage.
Page 47 Sets the slot power mode while the power is turned Allow Optional Terminal Board insert Slots while power V. Installation V. Installation function On/Off This mode is available for TH-65PHD8BK/EK/UK. Note: Turn up the power switch for the upward direction when you set display vertically. Rotate...
Page 48: Circuit Board Layout
and hold for more than 5 seconds. The “SHIPPING” menu is displayed and the lock is released when it disappears. 14. Circuit Board Layout 14.1. P-Board (P-1), (P-2) P(P-1) BOARD FOIL SIDE P(P-1) BOARD COMPONENT SIDE P(P-2) BOARD FOIL SIDE P(P-2) BOARD COMPONENT SIDE 14.2.
Page 49: Schematic Diagram Notes
14.17. SS-Board FOIL SIDE PARTS LOCATION COMPONENT SIDE 14.18. SS2 and SS3-Board 14.19. H3, S1 and V1-Board 15. Schematic Diagrams 15.1. Schematic Diagram Notes...
Page 50 15.2. Main Block Diagram 15.3. P-Board (1 of 2)Block Diagram 15.4. P-Board (2 of 2)Block Diagram 15.5. P-Board (1 of 3) Schematic Diagram 15.6. P-Board (2 of 3) Schematic Diagram 15.7. P-Board (3 of 3) Schematic Diagram 15.8. PB and V1-Board Block and Schematic Diagram 15.9.
Page 51 15.17. J-Board (2 of 4) Schematic Diagram 15.18. J-Board (3 of 4) Schematic Diagram 15.19. J-Board (4 of 4) Schematic Diagram 15.20. D-Board (1 of 2) Block Diagram 15.21. D-Board (2 of 2) Block Diagram 15.22. D-Board (1 of 12) Schematic Diagram 15.23.
Page 52: Parts Location
15.42. C4-Board (1 of 2) Schematic Diagram 15.43. C4-Board (2 of 2) Schematic Diagram 15.44. C5-Board (1 of 2) Schematic Diagram 15.45. C5-Board (2 of 2) Schematic Diagram 15.46. C6-Board (1 of 2) Schematic Diagram 15.47. C6-Board (2 of 2) Schematic Diagram 15.48.
Page 53 16.1.2. Escutcheon part location enlarged view...
Page 54: Cable Relation
16.1.3. Fan part location enlarged view 16.2. Cable relation...
Page 55: Packing Summary
16.3. Packing summary...
Page 57: Mechanical Replacement Parts List
K2CN3DH00006 AC CORD K2CT3DH00025 AC CORD (B/H) L6FALCEH0004 FAN (SC/SS) L6FALEFH0028 FAN (MIDDLE) L6FAPEHH0006 FAN (BIG) MD65H08A1J PLASMA DISPLAY PANEL TBMA165 PANASONIC BADGE TBXA38902 HINGE BUTTON TBXA44801 POWER BUTTON TESD031 SPRING TKGA5178-2T FRONT GLASS TKKC5105 LED PANEL TKKL5266 COVER BK/EK...
Page 58 Ref. No. Part No. Part Name & Description Remarks TKPA60301 REMOCON RECEIVER PANEL TKRA45301 HANDLE TMKG405 SPONGE (FAN BIG) TMKG469-1 SPONGE (FAN) TMKG572 CUSHION (TOP/BOTTOM) TMKG573 CUSHION (RIGHT/LEFT) TMMJ068 RUBBER (FAN) TMMX064-2 SPACER (A) TMMX070 SPACER (C) TMMX095 BRACKET TMWC014 POWER BUTTON BRACKET TPCB66101 CARTON BOX (BOTTOM)
Page 59: Replacement Parts List
Ref. No. Part No. Part Name & Description Remarks TXJSPL0YUS-1 SPEAKER LEAD (LEFT) TXJSPR0YUS-1 SPEAKER LEAD (RIGHT) XZBT6506 POLY BAG TMM15414-2 CLAMPER TMM17499 CLAMPER TMM25401 CLAMPER TMM6463-1 CLAMPER TMM6496-1 CLAMPER TMM7464-2 CLAMPER TMM7468-1 CLAMPER TMME002 CLAMPER TMME047 CLAMPER TMME061 CLAMPER TMME152 CLAMPER TMME185...
Page 60: Electrical Replacement Parts List
18.2. Electrical Replacement Parts List...
Page 61 Ref. No. Part No. Part Name & Description Remarks F401 HU216002BP CARTRIDGE FUSE F601,02 K5D103BMA001 TIME LAG FUSE HIGH F603,04 HU216005BP CARTRIDGE FUSE F701 HU216002BP CARTRIDGE FUSE F1601,02 K5D402BNA007 TIME LAG FUSE HIGH F1603 K5D102BNA007 TIME LAG FUSE HIGH A601,02 RA362MSV7 ARRESTOR K1MN50BA0076...
Page 62 C466-69 ECJ2FB1H104K C 0.1UF, K, 50V...
Page 63 Ref. No. Part No. Part Name & Description Remarks C471 ECJ2FB1H104K C 0.1UF, K, 50V C472 KZE1E470 ELECTROLYTIC CAPACITOR C473 ECJ3YB1E225K C 2.2UF, K, 25V C601 ECQU2A105ML PLASTIC FILM CAPACITOR C603,04 CD221K CERAMIC CAPACITOR C606 ECQU2A224ML PLASTIC FILM CAPACITOR C609 KZE1E101 ELECTROLYTIC CAPACITOR C610,11...
Page 64 C831 EEEHB1C470P C 47PF, J, 16V...
Page 65 Ref. No. Part No. Part Name & Description Remarks C832 ECJ1XB1C104K C 0.1UF, Z, 16V C833 ECJ1VB1H103K C 0.001UF, K, 50V C834 EEEHB1C470P C 47PF, J, 16V C835 F1J0J1060004 C 0.010UF, K, 16V C836 ECJ3YB1C225K C 0.022UF, K, 16V C837 F1J0J1060004 C 0.010UF, K, 16V C838...
Page 66 Ref. No. Part No. Part Name & Description Remarks C2350,51 ECJ3YB1C225K C 0.022UF, K, 16V C2352,53 EEEHB1H100P C 10PF, J, 50V C2354,55 EEEHB1V470P E 47UF, 35V C2356,57 ECJ2XB1H102K C 1000PF, K, 50V C2358,59 EEEHP1V2R2R E 2.2UF, 35V C2360,61 ECJ2XC1H102J C 1000PF, J, 50V C2362,63 EEEHB1E471UP C 470PF, J, 25V...
Page 67 Ref. No. Part No. Part Name & Description Remarks C3011 EEEHB1C470P C 47PF, J, 16V (HA) C3011 ECJ1XB1C104K C 0.1UF, Z, 16V (HB) C3012 ECJ1VF1H103Z C 0.010UF, Z, 50V C3012 ECJ2VF1C104Z C 0.1UF, Z, 16V (HB) C3012 ECJ1XB1C104K C 0.1UF, Z, 16V (HA) C3013 ECJ1VF1H103Z...
Page 68 Ref. No. Part No. Part Name & Description Remarks C3113 ECJ1XB1C104K C 0.1UF, Z, 16V (HB) C3114 ECJ3XF1C475Z C 4.7UF, Z, 16V C3114 ECJ1XB1C104K C 0.1UF, Z, 16V (HB) C3115 ECJ1XF1C104Z C 0.1UF, Z, 16V C3115 ECJ1XB1C104K C 0.1UF, Z, 16V (HB) C3116 ECJ3YB1C225K...
Page 69 Ref. No. Part No. Part Name & Description Remarks C3151 ECJ1XC1H330J C 33PF, J, 50V C3152 ECJ1XB1C104K C 0.1UF, Z, 16V C3153 ECJ1XC1H101J C 100PF, J, 50V C3154 ECJ1XB1C104K C 0.1UF, Z, 16V C3156 ECJ1XB0J105K C 1UF, K, 16V C3157 ECJ3XB0J106M C 10UF, M,6.3V C3158...
Page 70 Ref. No. Part No. Part Name & Description Remarks C3409 ECJ2VF1C104Z C 0.1UF, Z, 16V C3523 EEEHB1C470P C 47PF, J, 16V C3524 ECJ2VF1H103Z C 0.010UF, Z, 50V C3550 ECJ2VF1H103Z C 0.010UF, Z, 50V C3551 EEEHB1C470P C 47PF, J, 16V C3561,62 ECJ2VF1C105Z C 1UF, Z, 16V C6016,17...
Page 71 Ref. No. Part No. Part Name & Description Remarks C6425,26 EEUFC1E470 E 47UF, 25V C6432-35 TCUY1C105ZFN C 1UF, 16V C6436 ECJ3YB1E105K C 1UF, K, 25V C6437 TCUY1C105ZFN C 1UF, 16V C6440 TCUY1C105ZFN C 1UF, 16V C6442 TCUY1C105ZFN C 1UF, 16V C6444 TCUY1C105ZFN C 1UF, 16V...
Page 72 Ref. No. Part No. Part Name & Description Remarks C6816 F2A2G100A017 E 100UF, 400V C6818 ECJ2XB1H103K C 0.01UF, K, 50V C6819 TCUY1C105ZFN C 1UF, 16V C6820 ECJ2XB1H472K C 4700PF, K, 50V C6821 EEUFC1E221 E 220UF, 25V C6822 ECJ2XB1H104K C 0.1UF, K, 50V C6823 F1K2J222A014 C 2200UF, K,6.3V...
Page 73 Ref. No. Part No. Part Name & Description Remarks C7169 ECJ1XB1C104K C 0.1UF, Z, 16V C7201 TCUY1C105ZFN C 1UF, 16V C7203 TCUY1C105ZFN C 1UF, 16V C7207,08 ECJ1XB1C104K C 0.1UF, Z, 16V C7210 ECJ1XB1C104K C 0.1UF, Z, 16V C7212 TCUY1C105ZFN C 1UF, 16V C7214 ECJ1XB1C104K C 0.1UF, Z, 16V...
Page 74 Ref. No. Part No. Part Name & Description Remarks C7560 ECJ1XB1C104K C 0.1UF, Z, 16V C7563,64 ECJ1XB1C104K C 0.1UF, Z, 16V C7566,67 ECJ1XB1C104K C 0.1UF, Z, 16V C7601,02 TCUY1C105ZFN C 1UF, 16V C7611-13 ECJ1XC1H101J C 100PF, J, 50V C7624 TCUY1C105ZFN C 1UF, 16V C7630 ECJ1XB1C104K...
Page 75 Ref. No. Part No. Part Name & Description Remarks C8114 ECJ2VF1H103Z C 0.010UF, Z, 50V C8115 EEEHB1C470P C 47PF, J, 16V C8116 ECJ1VF1H103Z C 0.010UF, Z, 50V C8120 EEEHB1E330P C 33PF, J, 25V C8121 ECJ1XF1E104Z C 0.1UF, Z, 25V C8122 EEEHB1C470P C 47PF, J, 16V C8123...
Page 76 Ref. No. Part No. Part Name & Description Remarks C9235,36 ECJ1XF1C104Z C 0.1UF, Z, 16V C9241 ECJ1XF1C104Z C 0.1UF, Z, 16V C9373 ECJ1VF1H103Z C 0.010UF, Z, 50V C9375 EEEHB1C470P C 47PF, J, 16V C9377 ECJ1XF1C104Z C 0.1UF, Z, 16V C9379 EEEHB1C470P C 47PF, J, 16V C9383...
Page 77 Ref. No. Part No. Part Name & Description Remarks C9712 ECJ1XB1H102K C 1000UF, Z, 50V C9713 ECJ1XF1H102Z C 1000PF, Z, 50V C9715-17 TCUY1C105ZFN C 1UF, 16V C9718,19 ECJ1XF1C104Z C 0.1UF, Z, 16V C9721-23 ECJ1XF1C104Z C 0.1UF, Z, 16V C9724 ECJ1VC1H270J C 27PF, J, 50V C9725 ECJ1XB1C104K...
Page 78 Ref. No. Part No. Part Name & Description Remarks K1KA20AA0008 20P CONNECTOR K1KA20AA0009 20P CONNECTOR D31,32 K1MN55BA0076 55P CONNECTOR D33,34 K1MN68BA0076 68P CONNECTOR D332 RB550VA-30 DIODE D334 RB550VA-30 DIODE D335 RU-1P DIODE D337 RU-1P DIODE D375 ERJ6GEY0R00 M 0 OHM, 1/10W D401 RB550VA-30 DIODE...
Page 79 D3061 MA728 DIODE...
Page 80 Ref. No. Part No. Part Name & Description Remarks D3501-04 MA3056M ZENER DIODE D3507-10 MA8160H ZENER DIODE D6000-03 B0HBSN000008 DIODE D6004 B0HDSM000005 DIODE D6010,11 B0HBSN000008 DIODE D6012 B0ECHP000003 DIODE D6013,14 B0HCMM000014 DIODE D6015 B0ECHP000003 DIODE D6016 B0HBSN000008 DIODE D6020-22 B0HBSN000008 DIODE D6024,25 B0ECHP000003...
Page 81 Ref. No. Part No. Part Name & Description Remarks D6561,62 B0ECHP000003 DIODE D6563 B0HBSN000008 DIODE D6564-66 B0ECHP000003 DIODE D6567-70 B0JCME000037 DIODE D6571 B0ECHP000003 DIODE D6611,12 B0ECHP000003 DIODE D6613 MA8240M ZENER DIODE D6615,16 MA111 DIODE D6617 MA8051L ZENER DIODE D6618 B0HCMM000014 DIODE D6619 MA111...
Page 82 Ref. No. Part No. Part Name & Description Remarks D6837 MA8056H ZENER DIODE D6838,39 MA111 DIODE D6840 B0ECHP000003 DIODE D6841 B0HCMM000014 DIODE D6900,01 MA8056H ZENER DIODE D6902 B0ECHP000003 DIODE D6906 B0ECHP000003 DIODE D6920 MA8056H ZENER DIODE D6921 B0ECHP000003 DIODE D6925 B0ECHP000003 DIODE D6926...
Page 83 Ref. No. Part No. Part Name & Description Remarks K1KB22A00036 22P CONNECTOR IC401 F9222L INTEGRATED CIRCUIT IC701 F9222L INTEGRATED CIRCUIT IC801-03 C0DBAMH00013 IC804 C0CBCAC00275 IC850 C0DAAZG00014 IC901 MIP3E3SMY INTEGRATED CIRCUIT IC2301,02 C1BA00000383 IC2303 C1BB00001006 IC2305 C0ABBA000168 IC3001 MC14052BF MOS IC (CMOS GATE ARRLY) IC3001 C0JBAR000419 (HB)
Page 84 Ref. No. Part No. Part Name & Description Remarks IC6610 C0ZBZ0001033 IC6611 C0CBADC00075 IC6620 C0ZBZ0001033 IC6621 C0CBADC00075 IC6630 C0ZBZ0001033 IC6640 C0ZBZ0001033 IC6650,51 C0JBAZ000994 IC6652 C0CBALC00010 IC6653,54 C0CBADC00075 IC6801 C0DAAMH00005 IC6811,12 AN1431M LINEAR IC IC6814,15 AN1431M LINEAR IC IC6816 C0CBALC00010 IC6817,18 AN1431M LINEAR IC IC6900-05...
Page 85 Ref. No. Part No. Part Name & Description Remarks IC9701 MN102H90MPD IC9702 TVRN501-1 IC9703 TVRN647 IC9704 C0EBE0000447 IC9711 C0JBAE000354 IC9713 C0JBAS000215 IC9714 C0JBAZ000856 IC9715 C0JBAE000354 IC9953 C0DBEJG00001 IC9954 C0DBEGE00002 IP901 ERBSE0R75U MICRO FUSE K1KA20AA0335 20P CONNECTOR K1KA40AA0009 40P CONNECTOR K1KA11BA0051 11P CONNECTOR K1KA21B00008 21P CONNECTOR...
Page 86 Ref. No. Part No. Part Name & Description Remarks L801 G1C470MA0078 INDUCTOR COIL L802 G1C101MA0078 INDUCTION COIL L803 G1C220MA0078 INDUCTION COIL L804-11 J0JHC0000078 CHIP INDUCTOR L851 G0A680ZA0047 CHOKE COIL L901 EXCELSA35 BEAD CHOKE L902 EXCELDR35 FERRITE BEAD INDUCTOR L904 EXCELDR35 FERRITE BEAD INDUCTOR L1601,02 P2515303Z...
Page 87 Ref. No. Part No. Part Name & Description Remarks L6068 J0JJC0000021 CHIP INDUCTOR L6070 G0ZZ00002183 PEAKING COIL L6072 G0ZZ00002183 PEAKING COIL L6074 G0ZZ00002183 PEAKING COIL L6076 G0ZZ00002183 PEAKING COIL L6078 G0ZZ00002183 PEAKING COIL L6080 G0ZZ00002183 PEAKING COIL L6098 J0JJC0000021 CHIP INDUCTOR L6170 G0ZZ00002183 PEAKING COIL...
Page 88 Ref. No. Part No. Part Name & Description Remarks L9502 G1C150KA0038 INDUCTION COIL L9601-04 J0JHC0000096 CHIP INDUCTOR MC303 IXMM584M-C-9 MODULE MC401 IXMM584M-D-9 MODULE MC601 MP00P4 MODULE MC602 IXMM584M-J-9 MODULE MC604 MP00P6 MODULE MC605 IXMM584M-H-9 MODULE MC701 IXMM584M-E-9 MODULE MC801 IXMM584M-G-9 MODULE MC901 IXMM584M-H-9...
Page 89 Ref. No. Part No. Part Name & Description Remarks Q955,56 2SB1219A TRANSISTOR Q1540 2SD601A TRANSISTOR Q1601 2SK3302 FIELD EFFECT TRANSISTOR Q1602 2SD2098 TRANSISTOR Q1603 2SB1386RT100 TRANSISTOR Q1605 2SB709A TRANSISTOR Q1606 2SD601A TRANSISTOR Q2300 B1BBCF000028 TRANSISTOR Q2331 B1BBCF000028 TRANSISTOR Q2333,34 2SD601A TRANSISTOR Q2370,71 2SB709A...
Page 90 Q6223 B1DFKL000001 TRANSISTOR...
Page 91 Ref. No. Part No. Part Name & Description Remarks Q6225 B1DFKL000001 TRANSISTOR Q6230 B1ABNF000006 TRANSISTOR Q6231 B1ADNF000006 TRANSISTOR Q6232 B1ABNF000006 TRANSISTOR Q6233 B1ADNF000006 TRANSISTOR Q6240 2SB1193000LB TRANSISTOR Q6250-53 B1DFKM000002 TRANSISTOR Q6254 B1ABNF000006 TRANSISTOR Q6255 B1ADNF000006 TRANSISTOR Q6256 2SD1263A TRANSISTOR Q6257 2SC1473A TRANSISTOR Q6259...
Page 92 Ref. No. Part No. Part Name & Description Remarks Q6668 B1ABNF000006 TRANSISTOR Q6669 B1ADNF000006 TRANSISTOR Q6670 2SK620 Q6811 2SD1263A TRANSISTOR Q6812 2SB940A TRANSISTOR Q6813 2SC1473A TRANSISTOR Q6814 2SD1263A TRANSISTOR Q6815 2SC1473A TRANSISTOR Q6816 B1BBCJ000004 TRANSISTOR Q6817 2SD601A TRANSISTOR Q6818 2SB0709A TRANSISTOR Q6819 2SD1263A...
Page 93 Ref. No. Part No. Part Name & Description Remarks R369-71 ERJ6GEYJ823 M 82KOHM,J,1/10W R373-76 ERJ14YJ124 CHIP RESISTOR R386-91 ERJ6ENF2373 CHIP RESISTOR R397-99 ERJ14YJ124 CHIP RESISTOR R405 MPC5WR47KS METAL PLATE RESISTOR R406 ERJ6GEYJ223 M 22KOHM,J,1/10W R407 ERJ14YJ334 M 330KOHM, 1/2W R408 SG734K271 CHIP RESISTOR R410...
Page 94 Ref. No. Part No. Part Name & Description Remarks R678 ERJ12YJ680 M 68 OHM,J, 1/2W R679 ERJ12YJ151 M 150 OHM,J, 1/2W R705 ERJ6GEY0R00 M 0 OHM, 1/10W R706 ERJ14YJ334 M 330KOHM, 1/2W R707 ERJ14YJ470 M 47 OHM,J, 1/2W R708 ERJ14YJ334 M 330KOHM, 1/2W R709 MPC5WR56KS...
Page 95 Ref. No. Part No. Part Name & Description Remarks R907,08 ERJ14YJ104 M 100KOHM, J,1/4W R955 ERJ6GEYJ472 M 4.7KOHM,J,1/10W R957 ERJ6GEYJ103 M 10KOHM,J,1/10W R958 ERJ6GEYJ473 M 47KOHM,J,1/10W R959 ERJ6GEYJ681 M 680 OHM,J,1/10W R960 ERJ6GEYJ222 M 2.2KOHM,J,1/10W R961 ERG2FJS820D M 82 OHM, J, 2W R962 ERJ6GEYJ103 M 10KOHM,J,1/10W...
Page 96 Ref. No. Part No. Part Name & Description Remarks R2365 ERX1FJSR56D M0.56 OHM, J, 1W R2367 ERJ6GEYJ332 M 3.3KOHM,J,1/10W R2368,69 ERJ6GEYJ103 M 10KOHM,J,1/10W R2370 ERJ6GEYJ222 M 2.2KOHM,J,1/10W R2371,72 ERJ6GEYJ102 M 1KOHM,J,1/10W R2373 ERJ6GEYJ103 M 10KOHM,J,1/10W R2374 ERX1FJSR56D M0.56 OHM, J, 1W R2376 ERJ6GEYJ332 M 3.3KOHM,J,1/10W...
Page 97 Ref. No. Part No. Part Name & Description Remarks R3009 ERJ3GEYJ101 M 100 OHM,J,1/16W R3009 TAJAAH0101JV M 100 OHM,J,1/16W (HB) R3010 ERJ3GEYJ101 M 100 OHM,J,1/16W R3010 ERJ3GEYJ153 M 15KOHM,J,1/16W (HB) R3011 ERJ3GEYJ222 M 2.2KOHM,J,1/16W R3011 ERJ3GEYJ103 M 10KOHM,J,1/16W (HB) R3012 ERJ3GEYJ333 M 33KOHM,J,1/16W R3012...
Page 98 Ref. No. Part No. Part Name & Description Remarks R3031 ERJ3EKF4700 M 470 OHM, 1/16W (HB) R3032 ERJ3EKF1200 M 120 OHM, 1/16W (HB) R3032,33 J0JCC0000100 CHIP INDUCTOR R3033 TAJAAH0101JV M 100 OHM,J,1/16W (HB) R3034 ERJ3GEYJ331 M 330 OHM,J,1/16W R3035 ERJ3GEYJ331 M 330 OHM,J,1/16W R3035 ERJ3GEYJ102...
Page 99 Ref. No. Part No. Part Name & Description Remarks R3058 ERJ3GEYJ560 M 56 OHM,J,1/16W R3058 TAJAAH0101JV M 100 OHM,J,1/16W (HB) R3059 ERJ3GEYJ101 M 100 OHM,J,1/16W R3060 ERJ3GEYJ102 M 1KOHM,J,1/16W R3060 ERJ3GEYJ102 M 1KOHM,J,1/16W (HB) R3061 J0JCC0000100 CHIP INDUCTOR R3061 ERJ3GEYJ561 M 560 OHM,J,1/16W (HB) R3062...
Page 100 Ref. No. Part No. Part Name & Description Remarks R3124 ERJ3EKF10R0 M 10 OHM, 1/16W R3125 ERJ6GEYJ103 M 10KOHM,J,1/10W R3125 ERJ3GEY0R00 M 0 OHM, 1/16W (HB) R3126 J0JCC0000100 CHIP INDUCTOR R3127 J0JCC0000100 CHIP INDUCTOR R3127 ERJ6ENF12R0 M 12 OHM, 1/10W R3128,29 ERJ3GEYJ181 M 180 OHM,J,1/16W...
Page 101 Ref. No. Part No. Part Name & Description Remarks R3181 ERJ3EKF1401 M 1.4KOHM, 1/16W R3182 ERJ3EKF1101 M 1.1KOHM, 1/16W R3183 ERJ3EKF1401 M 1.4KOHM, 1/16W R3184 ERJ3EKF1101 M 1.1KOHM, 1/16W R3185 ERJ6GEY0R00 M 0 OHM, 1/10W R3188 ERJ6ENF39R0 M 39 OHM, 1/10W R3189 ERJ3GEY0R00 M 0 OHM, 1/16W...
Page 102 Ref. No. Part No. Part Name & Description Remarks R6012 ERJ6GEYJ101 M 100 OHM,J,1/10W R6013 ERJ6GEYJ100 M 10 OHM,J,1/10W R6014,15 ERJ6GEYJ103 M 10KOHM,J,1/10W R6020-25 ERJ14YJ100 M 10 OHM, J,1/4W R6032 ERJ6GEYJ101 M 100 OHM,J,1/10W R6033 ERJ6GEYJ100 M 10 OHM,J,1/10W R6034,35 ERJ6GEYJ103 M 10KOHM,J,1/10W R6040-43...
Page 103 Ref. No. Part No. Part Name & Description Remarks R6219 ERJ6GEYJ104 M 100KOHM,J,1/10W R6221 ERJ6GEYJ220 M 22 OHM,J,1/10W R6223 ERJ6GEYJ220 M 22 OHM,J,1/10W R6225 ERJ6GEYJ220 M 22 OHM,J,1/10W R6227 ERJ6GEYJ220 M 22 OHM,J,1/10W R6228 ERJ6GEYJ103 M 10KOHM,J,1/10W R6229 ERJ6GEYJ101 M 100 OHM,J,1/10W R6231 ERJ6GEYJ220 M 22 OHM,J,1/10W...
Page 104 Ref. No. Part No. Part Name & Description Remarks R6376 ERJ6ENF5602 M 56KOHM, 1/10W R6377 ERJ6ENF8202 M 82KOHM, 1/10W R6378 ERJ6ENF5762 M57.6KOHM, 1/10W R6379 ERJ6GEYJ563 M 56KOHM,J,1/10W R6380 ERJ6GEYJ473 M 47KOHM,J,1/10W R6382,83 ERX12SJ1R2 M 1.2 OHM, J,1/2W R6385 ERJ6GEYJ681 M 680 OHM,J,1/10W R6386 ERJ6GEYJ272 M 2.7KOHM,J,1/10W...
Page 105 Ref. No. Part No. Part Name & Description Remarks R6477 ERJ6GEYJ101 M 100 OHM,J,1/10W R6478-83 ERJ6GEYJ222 M 2.2KOHM,J,1/10W R6484 EXB38V470J RESISTOR ARRAY R6488 EXB38V470J RESISTOR ARRAY R6501-12 ERJ14YJ100 M 10 OHM, J,1/4W R6525-36 ERJ14YJ100 M 10 OHM, J,1/4W R6561 ERJ6GEYJ100 M 10 OHM,J,1/10W R6562 ERJ6GEYJ103...
Page 106 Ref. No. Part No. Part Name & Description Remarks R6735-37 ERJ6GEYJ224 M 220KOHM,J,1/10W R6738 ERJ6GEYJ104 M 100KOHM,J,1/10W R6739 ERJ6GEYJ182 M 1.8KOHM,J,1/10W R6740 ERJ6GEYJ203 M 20KOHM,J,1/10W R6741 ERJ6GEYJ222 M 2.2KOHM,J,1/10W R6742 ERJ6GEYJ470 M 47 OHM,J,1/10W R6743 ERJ6GEYJ104 M 100KOHM,J,1/10W R6744,45 ERJ6GEYJ472 M 4.7KOHM,J,1/10W R6746 ERJ6GEYJ100...
Page 107 Ref. No. Part No. Part Name & Description Remarks R6848 ERDS1FJ4R7 C 4.7 OHM, J,1/2W R6849,50 ERJ6GEY0R00 M 0 OHM, 1/10W R6851 ERJ12YJ103 M 10KOHM,J, 1/2W R6852 ERG2FJS101D M 100 OHM, J, 2W R6853 ERJ12YJ153U M 15KOHM, 1/2W R6854 ERJ6GEY0R00 M 0 OHM, 1/10W R6855 ERJ6GEYJ563...
Page 108 Ref. No. Part No. Part Name & Description Remarks R7121 ERJ12YJ2R2 M 2.2 OHM, J,1/2W R7122-24 TAJAAH0470JV M 47 OHM,J,1/16W R7126 EXB38V470J RESISTOR ARRAY R7127 ERJ12YJ2R2 M 2.2 OHM, J,1/2W R7128 EXB38V470J RESISTOR ARRAY R7130 ERJ3GEYJ681 M 680 OHM,J,1/16W R7131 ERJ12YJ2R2 M 2.2 OHM, J,1/2W R7133...
Page 109 Ref. No. Part No. Part Name & Description Remarks R7272,73 ERJ3GEY0R00 M 0 OHM, 1/16W R7274,75 ERJ3GEYJ220 M 22 OHM,J,1/16W R7276,77 ERJ3GEY0R00 M 0 OHM, 1/16W R7278,79 EXB38V470J RESISTOR ARRAY R7280,81 ERJ3GEYJ220 M 22 OHM,J,1/16W R7282,83 TAJAAH0470JV M 47 OHM,J,1/16W R7284,85 EXB38V681J RESISTOR ARRAY...
Page 110 Ref. No. Part No. Part Name & Description Remarks R7487,88 TAJAAH0470JV M 47 OHM,J,1/16W R7490 ERJ6GEYJ223 M 22KOHM,J,1/10W R7491 ERJ6GEYJ104 M 100KOHM,J,1/10W R7492-99 EXB38V681J RESISTOR ARRAY R7501,02 EXB38V681J RESISTOR ARRAY R7503 EXB38V470J RESISTOR ARRAY R7504,05 EXB38V681J RESISTOR ARRAY R7506-08 EXB38V470J RESISTOR ARRAY R7509-12 EXB38V681J...
Page 111 Ref. No. Part No. Part Name & Description Remarks R7614 ERJ3GEYJ681 M 680 OHM,J,1/16W R7615 ERJ3GEYJ681 M 680 OHM,J,1/16W R7615 ERJ12YJ2R2 M 2.2 OHM, J,1/2W R7616 EXB38V681J RESISTOR ARRAY R7616 TAJAAH0470JV M 47 OHM,J,1/16W R7617 EXB38V681J RESISTOR ARRAY R7617 TAJAAH0470JV M 47 OHM,J,1/16W R7618 EXB38V470J...
Page 112 Ref. No. Part No. Part Name & Description Remarks R8045,46 ERJ3GEYJ222 M 2.2KOHM,J,1/16W R8047 ERJ3GEYJ271 M 270 OHM,J,1/16W R8048-51 ERJ3GEYJ222 M 2.2KOHM,J,1/16W R8054 ERJ3GEYJ102 M 1KOHM,J,1/16W R8055,56 ERJ3GEYJ101 M 100 OHM,J,1/16W R8057 ERJ3GEYJ102 M 1KOHM,J,1/16W R8058,59 ERJ3GEYJ101 M 100 OHM,J,1/16W R8060 ERJ6ENF3300 M 330 OHM, 1/10W...
Page 113 Ref. No. Part No. Part Name & Description Remarks R9031 TAJAAH0101JV M 100 OHM,J,1/16W R9032 ERJ3GEYJ122 M 1.2KOHM,J,1/16W R9032 ERJ3GEY0R00 M 0 OHM, 1/16W R9033 TAJAAH0101JV M 100 OHM,J,1/16W R9034 ERJ3GEYJ122 M 1.2KOHM,J,1/16W R9034 ERJ3GEY0R00 M 0 OHM, 1/16W R9035-38 TAJAAH0101JV M 100 OHM,J,1/16W R9039-42...
Page 114 Ref. No. Part No. Part Name & Description Remarks R9211-20 TAJAAH0101JV M 100 OHM,J,1/16W R9221,22 TAJAAH0470JV M 47 OHM,J,1/16W R9223 ERJ3GEYJ103 M 10KOHM,J,1/16W R9225 ERJ3GEYJ103 M 10KOHM,J,1/16W R9227 ERJ3GEYJ103 M 10KOHM,J,1/16W R9229 ERJ3GEYJ103 M 10KOHM,J,1/16W R9237 TAJAAH0470JV M 47 OHM,J,1/16W R9238 EXB38V470J RESISTOR ARRAY...
Page 115 Ref. No. Part No. Part Name & Description Remarks R9427 EXB2HV470JV RESISTOR ARRAY R9428 EXB38V470J RESISTOR ARRAY R9429,30 EXB2HV470JV RESISTOR ARRAY R9431 ERJ3GEYJ103 M 10KOHM,J,1/16W R9432 EXB2HV470JV RESISTOR ARRAY R9433 ERJ3GEYJ220 M 22 OHM,J,1/16W R9434 ERJ3GEYJ103 M 10KOHM,J,1/16W R9435 EXB2HV470JV RESISTOR ARRAY R9436 ERJ3GEYJ220...
Page 116 Ref. No. Part No. Part Name & Description Remarks R9557 ERJ6GEY0R00 M 0 OHM, 1/10W R9558 ERJ3GEY0R00 M 0 OHM, 1/16W R9559 ERJ6GEY0R00 M 0 OHM, 1/10W R9560 ERJ6ENF1001 M 1KOHM, 1/10W R9562 ERJ6ENF1001 M 1KOHM, 1/10W R9567,68 EXB2HV470JV RESISTOR ARRAY R9569 EXB38V470J RESISTOR ARRAY...
Page 117 Ref. No. Part No. Part Name & Description Remarks R9684-86 ERJ3GEY0R00 M 0 OHM, 1/16W R9687 EXB38V470J RESISTOR ARRAY R9688 ERJ3GEY0R00 M 0 OHM, 1/16W R9689 ERJ3GEYJ472 M 4.7KOHM,J,1/16W R9690 EXB38V470J RESISTOR ARRAY R9696 ERJ3GEYJ103 M 10KOHM,J,1/16W R9697 EXB38V470J RESISTOR ARRAY R9698-00 ERJ3GEY0R00 M 0 OHM, 1/16W...
Page 118 Ref. No. Part No. Part Name & Description Remarks R9769 TAJAAH0101JV M 100 OHM,J,1/16W R9771 TAJAAH0101JV M 100 OHM,J,1/16W R9772,73 ERJ3GEY0R00 M 0 OHM, 1/16W R9774 ERJ3GEYJ102 M 1KOHM,J,1/16W R9775 ERJ3GEYJ123 M 12KOHM,J,1/16W R9777 ERJ3GEY0R00 M 0 OHM, 1/16W R9778,79 TAJAAH0101JV M 100 OHM,J,1/16W R9781...
Page 119 Ref. No. Part No. Part Name & Description Remarks R9849 D1HG33080001 NETWORK RESISTER R9850 ERJ3GEY0R00 M 0 OHM, 1/16W R9851 ERJ3GEYJ103 M 10KOHM,J,1/16W R9852 ERJ3GEYJ472 M 4.7KOHM,J,1/16W R9853-55 TAJAAH0101JV M 100 OHM,J,1/16W R9857 TAJAAH0101JV M 100 OHM,J,1/16W R9859 D1HG33080001 NETWORK RESISTER R9860 ERJ3GEYJ103 M 10KOHM,J,1/16W...
Page 120 Ref. No. Part No. Part Name & Description Remarks R9985 ERJ6GEY0R00 M 0 OHM, 1/10W R9986 ERJ3GEYJ153 M 15KOHM,J,1/16W R9991,92 ERJ3GEYJ103 M 10KOHM,J,1/16W R9993 TAJAAH0101JV M 100 OHM,J,1/16W R9995,96 ERJ3GEYJ103 M 10KOHM,J,1/16W RF601 HUF5K100J14 THERMAL CUTOFF WITH RESISTOR RF1601 HUF5K100J14 THERMAL CUTOFF WITH RESISTOR RM001 PNA4701M05TV...
Page 121 SD46 K1KA10B00209 10P CONNECTOR...
Page 122 Ref. No. Part No. Part Name & Description Remarks SDMM1 TMM25401 CLAMPER SS11 K1KA02AA0515 2P CONNECTOR SS12 K1KA10AA0194 10P CONNECTOR SS21 K1KA07A00170 7P CONNECTOR SS23 K1KB07AA0087 7P CONNECTOR SS25 K1KA07A00170 7P CONNECTOR SS27 K1KB07AA0087 7P CONNECTOR SS2MM1 TMME190 CLAMPER SS2MM3 TMME190 CLAMPER SS34...
Page 123: Schematic Diagram For Printing With A4
Ref. No. Part No. Part Name & Description Remarks ZD403 MA8056 ZENER DIODE ZD410 MA4220N ZENER DIODE ZD413 MA4270N ZENER DIODE ZD451 1ZB18 ZENER DIODE ZD701 MA4220N ZENER DIODE ZD702 PTZ24B ZENER DIODE ZD703 MA8056 ZENER DIODE ZD713 MA4270N ZENER DIODE ZD901,02 MA8270 ZENER DIODE...
Page 124 Parts Location SU-BOARD IC6900 TPSU1 IC6901 TPSU2 IC6902 TPSU3 IC6903 TPSU4 IC6904 TPSU5 IC6905 TPSU6 SU-BOARD (FOIL SIDE) TNPA3673 TNPA3673 1 SU REVERSE FOR ORDER 1 2 3 SUMM1 SU-BOARD (COMPONENT SIDE) TNPA3673 TPSU1 TPSU5 TPSU3 TPSU2 TPSU6 TPSU4 TNPA3673 ORDER 1 SU R6908...
Page 125 V1-BOARD (FOIL SIDE) TNPA3199AB S1554 S1553 S1550 S1551 S1552 IC1550 RM001 TNPA3199 SEE REVERSE FOR ORDER NO. 94V-0 V1-BOARD (COMPONENT SIDE) TNPA3199AB D1550 D1552 R1554 R1553 S1-BOARD (FOIL SIDE) S1-BOARD (COMPONENT SIDE) H3-BOARD TNPA3200AB TNPA3200AB TNPA3003 TNPA3003 SEE REVERSE FOR ORDERNO. TNPA3200 SEE REVERSE FOR ORDER NO.
Page 126 C1-BOARD TNPA3663 (1/2) ZA7101 ZA7102 ZA7103 ZA7104 K4CD01000013 K4CD01000013 K4CD01000013 K4CD01000013 D7101 VDA_75V B0HCMM000014 C7107 100V 0.47u D7102 B0HCMM000014 L7101 L7102 78V_R J0JJC0000011 J0JJC0000011 R7111 R7115 C7102 C1_5V TERM PANEL DATA DRIVER R7101 C7150 100p VDA_75V D7103 B0HCMM000014 C7103 100V D7104 0.47u B0HCMM000014...
Page 127 C1-BOARD TNPA3663 (2/2) R7173 R7174 EXB38V681JV EXB38V681JV C1_5_3V BUFFER 78V_R C7169 VDA_75V D7107 78V_R B0HCMM000014 0.1u 78.0 VDA_75V AA_DUC15 C7104 AA_DUB15 Vda 75V 100V AB_DUC15 0.47u 75.0 D7108 AA_DUA15 AB_DUB15 B0HCMM000014 AB_DUA15 AA_DUC14 AB_DUC14 AA_DUB14 78V_R L7105 L7106 R7126 EXB38V470JV J0JJC0000011 J0JJC0000011 AA_DUA14...
Page 128 C2-BOARD TNPA3664 (1/2) C2_5_3V D7201 VDA_75V B0HCMM000014 R7253 EXB38V681JV R7252 C7232 C7274 EXB38V681JV 100V 0.1u 0.47u D7202 AA_DUC15 B0HCMM000014 AA_DUB15 AB_DUC15 L7203 L7204 78V_L AA_DUA15 AB_DUB15 J0JJC0000011 J0JJC0000011 AB_DUA15 AA_DUC14 78V_R AB_DUC14 R7263 AA_DUB14 78V_R R7290 78.0 EXB38V470JV AA_DUA14 VDA_75V AB_DUB14 AA_CLR_R Vda 75V...
Page 129 C2-BOARD TNPA3664 (2/2) R7284 R7285 C2_5_3V EXB38V681JV EXB38V681JV BUFFER C7214 VDA_75V 0.1u D7205 B0HCMM000014 AA_DUC7 C7234 AA_DUB7 100V AB_DUC7 0.47u D7206 AA_DUA7 AB_DUB7 B0HCMM000014 AB_DUA7 78V_L L7207 AA_DUC6 78V_L L7208 AB_DUC6 J0JJC0000011 J0JJC0000011 AA_DUB6 R7286 EXB38V470JV AA_DUA6 D7209 B0HDSM000005 78V_R AB_DUB6 78V_L 78.0...
Page 130 R7392 R7393 EXB38V681JV EXB38V681JV C3-BOARD TNPA3665 (1/2) C3_5_3V BUFFER C7308 0.1u AA_DUC7 AA_DUB7 VDA_75V AB_DUC7 D7303 AA_DUA7 AB_DUB7 B0HCMM000014 AB_DUA7 AA_DUC6 AB_DUC6 C7359 100V AA_DUB6 D7304 R7303 0.47u EXB38V470JV B0HCMM000014 AA_DUA6 L7301 L7302 J0JJC0000011 J0JJC0000011 AB_DUB6 78V_L AA_ODE_L AB_DUA6 AA_CLR_L AB_ODE_L AB_CLR_L R7331...
Page 131 C3-BOARD TNPA3665 (2/2) VDA_75V D7305 B0HCMM000014 C7361 D7306 100V 0.47u B0HCMM000014 78V_L L7305 L7306 J0JJC0000011 J0JJC0000011 R7378 R7382 C3_5V C7340 CA10 TERM R7384 PANEL DATA R7374 DRIVER C7351 100p VDA_75V D7307 B0HCMM000014 C7362 100V 0.47u D7308 B0HCMM000014 L7307 L7308 78V_L J0JJC0000011 J0JJC0000011 R7377...
Page 132 C4-BOARD TNPA3666 (1/2) R7447 C4_5_3V_B C7406 0.1u NUEL CLKL NUEL DRV_SOS9 CLK11 DRV_SOS9 R7405 DRV_SOS2 NCLKL CLK12 DRV_SOS2 DMHR R7406 CLK21 DMHR R7407 DMLL CLK22 DMLL R7408 DMHL R7402 R7430 DMHL R7409 DSLL DSLL R7403 R7410 DSHL LE10 DSHL R7411 LE11 DRV_RST R7412...
Page 133 C4-BOARD TNPA3666 (2/2) ZA7401 ZA7402 ZA7403 ZA7404 K4CD01000013 K4CD01000013 K4CD01000013 K4CD01000013 VDA_75V D7411 B0HCMM000014 C7422 100V 0.47u D7412 B0HCMM000014 L7405 78V_L L7406 J0JJC0000011 J0JJC0000011 R7481 R7485 SS-BOARD (SS44) C4_5V NC(URH) NUEL C4_5V NUEL C7440 CB11 DRV_SOS9 DRV_SOS9 TERM NC(URL) R7472 PANEL DATA DMHR_BUF DRIVER...
Page 134 D-BOARD C5-BOARD TNPA3667 (1/2) (D34) TERM C5_5V C6-BOARD FL7501 (C60) J0HABH000013 R7565 R7564 EXB38V681JV EXB38V681JV R7511 R7512 EXB38V681JV EXB38V681JV AB_DDC20 C5_5_3V C5_5_3V_B DOUTDC[20] C5_5_3V AB_DDB20 BUFFER R7539 BUFFER DOUTDB[20] BUFFER AB_DDA20 C7558 C7505 DOUTDA[20] C7507 0.1u AB_DDC21 DOUTDC[21] 0.1u 0.1u AA_DDA15 AA_DDA13 AB_DDB21...
Page 135 C5-BOARD TNPA3667 (2/2) D-BOARD (D33) R7616 R7617 C5_5_3V EXB38V681JV EXB38V681JV BUFFER C7567 TERM 0.1u UEH_BUF USL_BUF C5_5V UML_BUF FL7502 R7618 J0HABH000013 EXB38V470JV NUEL UMH_BUF NUEL_BUF R7619 EXB38V470JV C4-BOARD (C41) R7613 R7517 R7518 R7568 R7569 UEH_BUF EXB38V681JV EXB38V681JV C5_5_3V R7566 R7567 EXB38V681JV EXB38V681JV EXB38V681JV...
Page 136 C6-BOARD TNPA3668 (1/2) ZA7601 ZA7602 K4CD01000013 K4CD01000013 VDA_75V D7601 B0HCMM000014 C7653 100V 0.47u D7602 B0HCMM000014 L7601 L7602 R7611 R7615 J0JJC0000011 J0JJC0000011 78V_R C6_5V C7602 TERM PANEL DATA DRIVER R7607 R7617 C7612 100p VDA_75V D7603 B0HCMM000014 C7654 100V 0.47u D7604 B0HCMM000014 R7609 R7613 L7603...
Page 137 C6-BOARD TNPA3668 (2/2) C5-BOARD (C50) R7681 BUFFER C6_5_3V_B C7630 0.1u CLKR CLK11 R7643 NCLKR CLK12 R7644 CLK21 R7645 CLK22 R7646 R7601 R7602 R7672 R7647 R7648 AA_DDC20 DOUTDC[20] AA_DDB20 R7649 DOUTDB[20] AA_DDA20 R7671 DOUTDA[20] VDA_75V AA_DDC21 D7607 DOUTDC[21] B0HCMM000014 AA_DDB21 DOUTDB[21] C7695 AA_DDA21 100V...
Page 138 D-BOARD (1/12) TZTNP01YUSE (TH-65PHD8BK/EK) FL9051 J0MAB0000175 ANF_R_S TZTNP020YUS (TH-65PHD8UK) ANF_G_S J-BOARD ANF_B_S EXPECT (J1) PHD8UK R/PR_S PHD8UK ONLY R9028 PR_M G/Y_S ANF_R_M R9029 ANF_G_M G/Y_M ANF_B_M B/PB_S 12V->3.3V/1.4A R9030 FL9001 J0MAB0000175 3.3V 12V->1.5V/2.0A PHD8UK ONLY B/PB_M P12V C9031 R9032 HD_S PHD8UK: 1.2k...
Page 139 R9171 BYTE DCK_M R9840 PHD8UK ONLY DQ15/A-1 AS_CLK R9175 DQ14 DCK_S R9179 DQ13 N.C. N.C. D-BOARD (2/12) DQ12 ABI_D TZTNP01YUSE (TH-65PHD8BK/EK) RESET R9839 C9734 C9733 N.C. DQ11 0.1u 4.7u TZTNP020YUS (TH-65PHD8UK) N.C. RY/BY DQ10 ABI_I ABI_J DG-BOARD TH-65PHD8 SERIES TH-65PHD8 SERIES...
Page 140 LVDSB_RXBP MAIN_B3 IC9201 IO_L24P_3 D-BOARD (3/12) M_BOUT3 SB_RX1- IC9201 IO_L01N_0/VRP_0 LVDSB_RXBN MAIN_B4 IC9201 M_BOUT4 SB_RX2+ MAIN_B5 IC9201 IO_L01P_7/VRN_7 LVDSB_RXCP TZTNP01YUSE (TH-65PHD8BK/EK) MAIN_B6 IC9201 IO_L16P_3 M_BOUT5 SB_RX2- IC9201 IO_L01N_7/VRP_7 LVDSB_RXCN MAIN_B7 IC9201 IO_L19P_3 M_BOUT6 SB_RX3+ IC9201 IO_L17P_7 LVDSB_RXDP TZTNP020YUS (TH-65PHD8UK) IC9201...
Page 141 D-BOARD (4/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) IC9103 C0JBAE000354 2.5V->3.3V 3.3V LEVEL CONVERTER C9108 3.3V 0.1u IC9304 IC9305 L9502 C9654 G1C150KA0038 6.3V IC9306 C0JBAZ000856 C0JBAZ000856 R9611 4.7k C0JBAZ000856 TDO_2V 3.3V->5V 3.3V->5V C9650 LEVEL CONVERTER LEVEL CONVERTER 3.3V->5V TDO_57 0.1u LEVEL CONVERTER R9149 2.5V_3...
Page 142 D-BOARD (5/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) FL9305 FL9304 POWER 2.5V_L8 1.5V 1.5V_L8 2.5V_2 F1J1E1040022 F1J1E1040022 C9441 220u FL9502 3.3V 3.3V_L78 F1J1E1040022 3.3V_L78 C9387 IC9302 IC9302 IC9302 VDD33 16V 0.1u C9764 C9388 IC9302 IC9302 IC9302 VDD33 16V 0.1u 220u C9389 IC9302...
Page 143 1.1k IC9302 AB14 BIAS C9425 R9494 3.16k 0.1u 2.5V_L8 R9495 IC9302 AC16 VREF C9442 R9496 0.1u D-BOARD (6/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) DG-BOARD TH-65PHD8 SERIES TH-65PHD8 SERIES (12/12) D-Board (6 of 12) Schematic Diagram D-Board (6 of 12) Schematic Diagram...
Page 144 D-BOARD (7/12) DG-BOARD (1/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) P12V J-BOARD (J3) R9995 FL9707 STB5V_M F1J1E1040022 R9993 Q9078 R9986 B1ABCF000138 STB3.3V R9881 STB5V AR_IIC_CONT 5V_SCL3 3V_SCL3 P12V IIC_CONT R9882 R9479 EXB38VR000V 3V_SCL1 SCL1 3V_SDA1 SDA1 R9992 5V_SCL3 SCL3 5V_SDA3 SDA3 N.C.
Page 145 D-BOARD (8/12) DG-BOARD (2/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) C9726 D9707 R9808 MA2J72800L 1000p STB3.3V C9709 0.1u STB3.3V R9810 C9594 R9826 R9805 0.1u R9701 Q9707 AAE_MCCLK R9803 R9785 B1ABCF000138 AAE_MCDATA_O R9828 AA_REMOCON R9797 3.3V R9829 SDA2 R9827 R9801 P65/A06 PC4/SDA1 R9834...
Page 146 B1ABCF000138 R9289 R9286 C9234 R9287 Q9202 0.01u B1ABCF000138 2.5V_3 R9283 4.7k R9284 VOUT C9241 0.1u D-BOARD (9/12) IC9202 C0EBD0000038 TZTNP01YUSE (TH-65PHD8BK/EK) RESET TZTNP020YUS (TH-65PHD8UK) TH-65PHD8 SERIES TH-65PHD8 SERIES D-Board (9 of 12) Schematic Diagram D-Board (9 of 12) Schematic Diagram...
Page 147 D-BOARD (10/12) DG-BOARD (4/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) 1.5V_L7 C9662 IC9501 VDD15 16V 0.1u C9663 IC9501 VDD15 16V 0.1u C9664 IC9501 VDD15 16V 0.1u C9665 IC9501 IC9501 IC9501 VDD15 16V 0.1u C9666 IC9501 IC9501 IC9501 VDD15 16V 0.1u IC9501 C9667...
Page 148 D-BOARD (11/12) DG-BOARD (5/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) IC9501 MN845111-A IC9302 TIOCTL0 L8_R0 L8_PCK IC9302 IC9302 IC9302 TIOCTL1 SIGNAL PROCESSOR L8_R1 IC9302 3.3V FORMAT CONVERTER IC9302 TCKSEL0 3.3V_L78 L8_R2 IC9302 IC9302 TCPOUT IC9302 TCKSEL1 R9413 L8_R3 IC9302 IC9302 TCKSEL2 IC9302...
Page 149 D-BOARD (12/12) DG-BOARD TZTNP01YUSE (TH-65PHD8BK/EK) (6/12) TZTNP020YUS (TH-65PHD8UK) DDR-SDRAM C9439 0.1u 2.5V_L8 IC9302 R9497 MN845121-A R9498 PLASMA AI SUB-FIELD PROCESSOR DRVCLKD0 L8DO_DA0 L8DO_DB0 L8DO_DC0 IC9302 DRVCLKD0 IC9302 DOUTDA00 IC9302 DOUTDB00 IC9302 DOUTDC00 DRVCLKD1 L8DO_DA1 L8DO_DB1 L8DO_DC1 IC9302 DRVCLKD1 IC9302 DOUTDA01...
Page 150 HA-BOARD TXNHA10RBS L3001 J0HABB000004 LAN15V LAN15V JS3011 JS3014 COMPONENT HA BNC TP032 L3002 VIDEO IN J0HABB000004 COMPONENT VIDEO JS3012 JS3015 TP033 TP034 L3003 J-BOARD J0HABB000004 JK3001 SLOT -0.8 JS3013 JS3016 K1QBB3BB0002 JK3001 COMPONENT VIDEO IN PB/B AB_AUD_R PLUG_DET PR/R JK3002 R3041 AUD_R TP035...
Page 151 IC3101 AVR 2.5V C0DBEZG00004 HB-BOARD TXNHB10QXS (1/2) C3127 3.3V IC3104 R3145 C3159 220u AD2R5V C0EBE0000066 R3112 1.5k RESET R3159 C3105 C3102 R3113 C3103 R3144 R3185 0.1u 1.5k 220u R3143 C3142 C3144 C3132 C3133 C3179 0.1u 0.1u 0.1u 0.1u GC3R3V GC2R5V IC3003 C3012 220u...
Page 152 HB-BOARD TXNHB10QXS (2/2) C3266 C3265 220u 0.1u 3.3V TS3100 AE_V_Y TS3101 TS3102 AL_S2_DET R3251 AM_HS IC3251 LVDS TRANSMITTER C0ZBZ0000684 AM_VS AE_R AE_L SCL2 SDA2 3.3V L3252 L3251 ELJPA2R2MF ELJPA2R2MF 3.3V C3261 C3264 220u 0.1u 3.3V AI_TX3+ AI_TX3- AJ_TXC+ AJ_TXC- AH_TX2+ AH_TX2- AK_TX1+ AK_TX1-...
Page 153 HX-BOARD TZTNP040VAS L3555 ELJPA100KF C3405 R3653 C3550 C3551 C3404 C3561 Q3531 2SD0601A0L 0.01u JK3513 0.1u K2HC103B0105 R3776 R3668 R3654 R3663 FL3512 R3547 J0HAAB000012 IC3502 PC AUDIO IN R3529 180k R3655 PC-R C3562 Q3532 R3548 DDC EEPROM 2SD0601A0L TO J14 R3530 R3777 PC-G PC-G...
Page 154 J-BOARD (1/4) TNPA3630AD (65PHD8BK/EK) TNPA3630AC (65PHD8UK) IC801 C0DBAMH00013 D_3.3V D_1.8V DIG12V AVR 9V 9V/0.5A R801 C807 C802 4.7u 470u L801 G1C470MA0078 R802 R808 C806 C809 0.1u 2.2u R805 RESET 84.5k IC2301 10W MONO C805 BTL AMP R R825 C808 C801 C1BA00000383 R803 8.2k...
Page 155 3.3V STB3.3V R3125 IC8001 SLOT1 C0JBAR000241 C8035 SLOT2 C8003 R3163 Q8002 SLOT3 0.1u 0.1u SYNC SELECT(MAIN) 2SD0601A0L C8001 R8072 R8047 R8001 L8001 R3134 C8049 IC8007 G1C100K00020 R8036 100k R8002 R8009 C8027 R8035 0.01u R8010 C0JBAR000419 2.2u R8003 IC3008 SYNC SWITCH(MAIN) R8004 R8011 R8017...
Page 156 SYNC SIGNAL IC8003 PROCESSOR TPJH1 TPJV1 C1AA00000706 (MAIN) L8003 R8065 G1C100K00020 AG_HD_M AG_VD_M H.State Clamp Timing C8036 R8067 V.State R8041 V.Pol. 100p C8045 Green Sep Filter L8005 H.Pol. C8029 G1C100K00020 C8025 R8033 Green IN 0.01u Clamp OUT TPJH2 TPJV2 100k 0.01u R8056 R8068...
Page 157 IC8014 C0ZBZ0000911 STB3.3V RS232C DRIVER C8084 SHUTDOWN C8081 C8080 0.1u 0.1u AJ_TXD_4 T1_OUT AJ_RXD1 R8124 AJ_RXD_4 C8082 R1_IN R8125 AJ_TXD1 AJ_RXD4 0.1u R1_OUT R8126 ONLINE C8083 AJ_TXD4 T2_OUT T1_IN 0.1u R8127 R2_IN T2_IN R2_OUT STATUS IC3150 D-BOARD (D5) C0JBAA000419 R3060 STB5V_S D3005 LNJ206R5ARA...
Page 158: Important Safety Notice
Important Safety Notice Components identified by mark have special characteristics important for safety. When replacing any of these components, use only manufacture's specified parts. Notes: 1. Resistor Unit of resistance is OHM [ ] (K=1,000, M=1,000,000). 2. Capacitor Unit of capacitance is F, unless otherwise noted.
Page 159 Remarks: 1. The Power Circuit contains a circuit area which uses a separate power supply to isolate the earth connection. The circuit is defined by HOT and COLD indications in the schematic diagram. Take the follwing precautions. All circuits, except the Power Circuit, are cold. Precautions a.
Page 160 COLD SS-BOARD (SS12) K5D402BNA007 AC_IN K5D402BNA007 CN03 J-BOARD (J10) SC BOARD (SC23) J-BOARD (J4) PB-BOARD (PB30) COLD D-BOARD (D25) CN01 K5D102BNA007 CN02 P-BOARD ETXMM584MEK (1/3) COLD TH-65PHD8 SERIES TH-65PHD8 SERIES P-Board (1 of 3) Schematic Diagram P-Board (1 of 3) Schematic Diagram...
Page 161 P-BOARD ETXMM584MEK (2/3) TH-65PHD8 SERIES TH-65PHD8 SERIES P-Board (2 of 3) Schematic Diagram P-Board (2 of 3) Schematic Diagram...
Page 162 SC-BOARD (SC2) SS-BOARD (SS11) K5D103BMA001 CN05 K5D103BMA001 CN06 COLD COLD CN08 P-BOARD ETXMM584MEK (3/3) TH-65PHD8 SERIES TH-65PHD8 SERIES P-Board (3 of 3) Schematic Diagram P-Board (3 of 3) Schematic Diagram...
Page 163 FAN CONTROL IC850 REGULATOR FAN A +9V/+7.2V L6FALCEH0004 VOLTAGE CONTROL TO FAN D850 R854 FAN B Q850 L6FALCEH0004 TO P30 JS851 +15V P-BOARD D851 FAN SOS (P30) R860 R861 R858 R857 R856 R855 R854 1.2k 1.2k 1.2k 1.2k 1.2k 1.2k 1.2k R855 15.0...
Page 164 S2(CMH) VSUS TPVSUS R6375 C6502 C6504 C6506 C6509 Q6551 P-BOARD C6503 C6507 C6508 C6510 250V 250V 250V 250V 250V 250V 250V 250V Q6501 B1ABNF000006 R6501 10 2.2u 2.2u 2.2u 2.2u 2.2u 2.2u 2.2u 2.2u (P2) B1JADN000002 C6511 L6414 630V R6376 R6502 10 182.0 G0ZZ00002183...
Page 165 TP061 Q6814 D6813 D1FL40 R6827 2SD1263AP0LB D6831 C6812 C6813 C6814 C6815 D6814 R6886 MA2J11100L 630V 630V 630V R6831 R6807 3300p D1FL40 COLD FLOATING GND 220k 100k 630V 3300p 3300p 3300p R6829 C6821 100k R6828 D6818 L6814 220u 100k R6876 C6840 D1FS6 R6832 R6808...
Page 166 SU-BOARD SU-BOARD SC41 (SU41) SC42 (SU42) ZA6401 K4CD01000013 SU-BOARD ZA6402 (SU45) K4CD01000013 TP032 AA_FSIU AA_FSIU ZA6403 K4CD01000013 TP033 AA_FCLU TP034 AA_FCLU AA_FCLKU VF+5V TP035 AA_PROU AA_FCLKU 5V_F TP036 AA_PROU SD-BOARD SD-BOARD SC43 SC44 (SD43) (SD44) Vfo(Vscn Out) (Vscn Voltage) (Vscn Voltage) TP037 TP049...
Page 167 SD-BOARD TNPA3674 (1/2) To 1st 96pins of To 2nd 96pins of SCAN ELECTRODES SCAN ELECTRODES AF_411 AF_422 AE_475 AE_486 AD_539 AD_550 AF_410 AF_423 AE_474 AE_487 AD_538 AD_551 AF_409 AF_424 AE_473 AE_488 AD_537 AD_552 AF_408 AF_425 AE_472 AE_489 AD_536 AD_553 OUT41 OUT24 OUT41 OUT24...
Page 168 SD-BOARD TNPA3674 (2/2) To 3rd 96pins of To 4th 96pins of SCAN ELECTRODES SCAN ELECTRODES AC_603 AC_614 AB_667 AB_678 AA_731 AA_742 AC_602 AC_615 AB_666 AB_679 AA_730 AA_743 AC_601 AC_616 AB_665 AB_680 AA_729 AA_744 AC_600 AC_617 AB_664 AB_681 AA_728 AA_745 OUT41 OUT24 OUT41 OUT24...
Page 169 Q6100 SS53 B1JADN000002 R6100 C6080 C6100 250V 630V 2.2u 5600p R6101 SS-BOARD TNPA3670 (1/2) R6138 R6139 R6137 R6136 Q6118 C6081 B1ABNF000006 R6102 250V Q6101 2.2u B1JADN000002 SS2-BOARD D6135 C6082 250V MA2J11100L TNPA3671 2.2u R6103 PANEL SUSTAIN C6083 Q6102 250V ELECTRODE 2.2u R6104 B1JADN000002...
Page 170 C6202 470u L6223 J0JJC0000021 D6206 D1FL40 C6207 C6206 160V 160V Vda_75V Vda_75V 100u 100u Q6007 Q6200 R6219 2SB792ATX R6245 R6210 Q6210 2SK326900L 100k 5.9k B1ABNF000006 R6192 R6193 D6240 150k R6053 DF20LC20U R6240 R6243 D6241 R6200 71.5k C6114 D1FL40 D6242 R6212 JS6201 D1FL40 R6211...
Page 171 SU-BOARD TNPA3673 (1/2) To 1st 96pins of To 2nd 96pins of SCAN ELECTRODES SCAN ELECTRODES AF_27 AF_38 AE_91 AE_102 AD_155 AD_166 AF_26 AF_39 AE_90 AE_103 AD_154 AD_167 AF_25 AF_40 AE_89 AE_104 AD_153 AD_168 AF_24 AF_41 AE_88 AE_105 AD_152 AD_169 OUT41 OUT24 OUT41 OUT24...
Page 172 SU-BOARD TNPA3673 (2/2) To 3rd 96pins of To 4th 96pins of SCAN ELECTRODES SCAN ELECTRODES AC_219 AC_230 AB_283 AB_294 AA_347 AA_358 AC_218 AC_231 AB_282 AB_295 AA_346 AA_359 AC_217 AC_232 AB_281 AB_296 AA_345 AA_360 AC_216 AC_233 AB_280 AB_297 AA_344 AA_361 OUT41 OUT24 OUT41 OUT24...
Page 173 15 Schematic Diagrams 15.1. Schematic Diagram Notes...
Page 174 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK...
Page 175: Main Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.2. Main Block Diagram S.R. S.R. S.R. S.R. S.R. S.R. S.R. DATA DRIVER DATA DRIVER SCAN OUT DIGITAL SIGNAL PROCESSOR (1.2V)3.3V SC23 1.5V STB3.3V DC/DC VSUS CONVERTER DISCHARGE SC20 CONTROL CONTROL MAIN MPU SOS1 EEPROM...
Page 176 S.R. S.R. S.R. S.R. S.R. 78V_L 78V_R Vda_75V DATA DRIVER PB31 FANx7 PB32 CONTROL PB33 PB34 PB30 PB35 PB37 PB38 SS35 VSUS 15VD STBY5V POWER OUTPUT Vda 75V +12V 78V_L SW_MAIN CONTROL 5V,15V 78V_R FAN CONT ON/OFF PS_SOS FAN SOS +5VC STBY5V +12VC...
Page 177: P-Board (1 Of 2)Block Diagram
15.3. P-Board (1 of 2)Block Diagram CN04 CNPFC RF1601 3A L1604 POWER SUPPLY MC1604 MC1601 AC IN (1/2) RECTIFIER K1601 K1602 L1601 L1602 LIVE DC(+) F1601 NEUTRAL DC(-) F1602 Z1602 CN03 (2/2) LIVE Q1606 Q1605 NEUTRAL BIAS MC1602 Q1602 GATE Q1603 ON/OFF PFC_ON...
Page 178 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK CNPFC D709 CN02 T701 (2/2) F701 VS_OUT Q703 VS_OHP IC701 ZD702 PFC_ON VS_STOP ZD703 HV_ON VR701 ZD701 ZD713 SC23 15VD 15VD 15VC POWER MODULE L456 MC701 Exchanged board only POWER CONTROL 15VS 15VS 15VS COLD...
Page 179: P-Board (2 Of 2)Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.4. P-Board (2 of 2)Block Diagram POWER SUPPLY (2/2) MC601 PFC(POWER FACTOR CONTROL) RF601 3A L604 MC604 CN05 RECTIFIER (1/2) K601 K602 L601 L602 LIVE DC(+) F601 F603 Z601 Z602 NEUTRAL DC(-) F602 S1 G1 S2 G2...
Page 180 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK COLD SS-BOARD (SS12) J-BOARD (J10) SC BOARD (SC23) J-BOARD (J4) PB-BOARD (PB30) COLD D-BOARD (D25) CN01 CN02 COLD TH-65PHD8 SERIES P-Board (1 of 3) Schematic Diagram...
Page 181: P-Board (1 Of 3) Schematic Diagram
15.5. P-Board (1 of 3) Schematic Diagram K5D402BNA007 AC_IN K5D402BNA007 CN03 CN01 K5D102BNA007 P-BOARD ETXMM584MEK (1/3) TH-65PHD8 SERIES P-Board (1 of 3) Schematic Diagram...
Page 182 COLD Vsus VSUS F603 VR351 VSUS SS11 VSUS MC301 Vsus POWER SUPPLY ZD301 ZD302 COLD F604 CN06 (1/2) VS_OUT VS_OHP MC302 TH301 Vsus POWER SUPPLY ZD303 PFC_ON Q332 VS_STOP Q333 ZD304 HV_ON COLD TH-65PHD8 SERIES P-Board (2 of 2) Block Diagram...
Page 183: P-Board (2 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.6. P-Board (2 of 3) Schematic Diagram P-BOARD ETXMM584MEK (2/3) TH-65PHD8 SERIES P-Board (2 of 3) Schematic Diagram...
Page 184 TH-65PHD8 SERIES P-Board (2 of 3) Schematic Diagram...
Page 185: P-Board (3 Of 3) Schematic Diagram
15.7. P-Board (3 of 3) Schematic Diagram K5D103BMA001 CN05 K5D103BMA001 CN08 P-BOARD ETXMM584MEK (3/3) TH-65PHD8 SERIES P-Board (3 of 3) Schematic Diagram...
Page 186 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK SC-BOARD (SC2) SS-BOARD (SS11) CN06 COLD COLD CN08 TH-65PHD8 SERIES P-Board (3 of 3) Schematic Diagram...
Page 187: Pb And V1-Board Block And Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.8. PB and V1-Board Block and Schematic Diagram FAN CONTROL IC850 REGULATOR FAN A +9V/+7.2V L6FALCEH0004 VOLTAGE CONTROL D850 R854 FAN B Q850 L6FALCEH0004 TO P30 +15V P-BOARD D851 FAN SOS (P30) R855 15.0 DR15V...
Page 188 TO FAN JS851 R860 R861 R858 R857 R856 R855 R854 1.2k 1.2k 1.2k 1.2k 1.2k 1.2k 1.2k 15.0 D856 D857 D853 D852 D851 D850 D854 MA2C165001VT MA2C165001VT MA2C165001VT MA2C165001VT MA2C165001VT MA2C165001VT MA2C165001VT IC850 C0DAAZG00014 FAN CONTROL REGULATOR C850 0.1u TPFAN L851 JS852 R862...
Page 189: Ha-Board Block And Schematic Diagram
15.9. HA-Board Block and Schematic Diagram HA-BO HA BNC COMPONENT VIDEO J-BOARD SLOT JK3001 COMPONENT VIDEO IN PB/B PR/R JK3002 K2HA204B0097 SLOT+9V Q3001 AUDIO IN L AMP JK3002 AUDIO IN L COMPONENT R3022 AUDIO IN R AUDIO IN Q3002 R AMP R3023 IC3002 EEPROM...
Page 190 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK HA-BOARD TXNHA10RBS L3001 J0HABB000004 LAN15V LAN15V JS3011 JS3014 COMPONENT TP032 L3002 VIDEO IN J0HABB000004 JS3012 JS3015 TP033 TP034 L3003 J0HABB000004 JK3001 -0.8 JS3013 JS3016 K1QBB3BB0002 AB_AUD_R PLUG_DET K3002 R3041 AUD_R TP035 L3006 A204B0097 AB_AUD_L AA_SCL2...
Page 191: Hb-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.10. HB-Board Block Diagram HB BNC COMPOSITE VIDEO / S_VIDEO IC3103 GC2M IC3003 Q3006 Q3101,3102 BUFFER BUFFER Q3002 JK3001 IC3001 Analog Adaptive Front-End Comb IC3002 S-VIDEO IN Filter SWITCH NTSC JK3002 Q3007 Q3104 L.P .F.
Page 192 IC3104 IC3201 RESET MEMORY FIFO 3103 IC3251 LVDS TRANSMITTER J-BOARD SLOT MEMORY CONTROLLOR TX0+ TX0+ TX0- TX0- TX1+ TX1+ Color TX1- 2DScalar Output TX1- nalog Adaptive Decoder ont-End Comb Formatter TX2+ NTSC TX2+ Filter Panorama Mixer TX2- Contast SECAM TX2- NTSC Brightness TX3+...
Page 193: Hb-Board (1 Of 2) Schematic Diagram
15.11. HB-Board (1 of 2) Schematic Diagram IC310 C0DBEZG HB-BOARD TXNHB10QXS (1/2) IC3003 C3012 0.1u C0ABGB000001 IC3102 C3005 C0DBZLB00001 0.1u ERROR DET R3010 Q3001 C3001 L3001 2SD0601A0L J0HABB000003 D3001 0.1u MA2J72900 R3022 CROMA C3002 R3016 D3002 0.1u MAZ31000ML R3106 R3030 R3032 C3014 R3019...
Page 194 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK IC3101 AVR 2.5V C0DBEZG00004 C3127 3.3V IC3104 R3145 C3159 220u AD2R5V C0EBE0000066 R3112 1.5k RESET R3159 C3105 C3103 C3102 R3113 R3144 R3185 0.1u 1.5k 220u R3143 C3142 C3144 C3132 C3133 C3179 0.1u 0.1u 0.1u 0.1u...
Page 195: Hb-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.12. HB-Board (2 of 2) Schematic Diagram HB-BOARD TXNHB10QXS (2/2) C3266 C3265 220u 0.1u 3.3V TS3100 TS3101 TS3102 AE_V_Y AL_S2_DET R3251 AM_HS IC3251 LVDS TRANSMITTER C0ZBZ0000684 AM_VS AE_R AE_L SCL2 SDA2 3.3V L3252 L3251 ELJPA2R2MF ELJPA2R2MF 3.3V...
Page 196 SCL2 SDA2 3.3V AI_TX3+ AI_TX3- AJ_TXC+ AJ_TXC- AH_TX2+ AH_TX2- AK_TX1+ AK_TX1- AD_TX0+ AD_TX0- J-BOARD SLOT 103FA L3308 KE103FA FACTORY STB5V SCL2 SDA2 SDA2 SCL2 R3309 R3307 SCL2 SDA2 TH-65PHD8 SERIES HB-Board (2 of 2) Schematic Diagram...
Page 197: Hx-Board Block And Schematic Diagram
15.13. HX-Board Block and Schematic Diagram IC3502 PC-R DDC EEPROM TO J14 PC-G PC-G PC-G PC-B PC-B PC-B PC-R PC-R PC-HD JK3511 PC-HD_HX PC-HD PC IN PC-VD PC-VD_HX PC-VD PC_AUDIO_IN_R STB5V STB+5V PC-AUDIO_IN_L PC-TXD PC-RXD JK3513 AUDIO IN JK3509 RS232C PC TYPE INPUT TERMINAL TH-65PHD8 SERIES...
Page 198 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK HX-BOARD TZTNP040VAS L3555 ELJPA100KF C3550 C3405 R3653 C3551 C3404 Q3531 C3561 0.01u 2SD0601A0L JK3513 0.1u K2HC103B0105 R3776 R3654 R3668 R3663 FL3512 R3547 J0HAAB000012 R3529 PC AUDIO IN R3655 180k Q3532 C3562 R3548 2SD0601A0L R3530 R3777...
Page 199: J-Board (1 Of 2) And H3-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.14. J-Board (1 of 2) and H3-Board Block Diagram SLOT INTERFACE/SYNC PROCESSOR/SOUND PROCESSOR TO P5 DIG+12V DIG+12V DR15V AUDIO+12V AUDIO+12V AUDIO+12V Q2370 Q2371 12V DET 12V DET Q2372 MUTE SW D2303 Q2334 Q2333 12V DET...
Page 200 S_CLOCK3 S_DATA3 RESET AUDIO MUTE AUDIO L AUDIO R AMP_STB_SW IC2301 DIG12V 10W MONO BTL AMP R JK8500 +R OUT SP_R+ R OUT -R OUT SP_R- L OUT IC2305 EQUALIZER IC2302 AMP_STB_SW 10W MONO BTL AMP L JK8500 +L OUT SP_L+ -L OUT SP_L-...
Page 201: J-Board (2 Of 2) Block Diagram
15.15. J-Board (2 of 2) Block Diagram J SLOT INTERFACE/SYNC PROCESSOR/SOUND PROCESSOR STB3.3V S_CLOCK3 IC3008 AA_SCL3 S_DATA3 IC3004 AA_SDA3 STB5V IIC ON/OFF IC3007 STB5V EX.I/O(SLOT DET IIC CONTRO AB_SCL3 AB_SCL3 IIC ON/OFF AB_SDA3 AB_SDA3 AC_SCL3 AA_SCL3 RESET 3.3V OUTPUT PORT RESET AC_SDA3 AA_SDA3...
Page 202 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK TO HX1 STB5V EX I/O(VIDEO/AUDIO SELECT) IC3003 (MAIN) LOT DET IIC CONTROL) STB5V IC8014 AH_SLOT1_DET AC_SW0 OUTPUT PORT OUTPUT PORT(SW0) AC_SW1 RS232C AH_SLOT2_DET OUTPUT PORT(SW1) DRIVER OUTPUT PORT AE_SW0 AH_SLOT3_DET OUTPUT PORT(SW0) OUTPUT PORT AE_SW1 STB3.3V...
Page 203: J-Board (1 Of 4) And H3-Board Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.16. J-Board (1 of 4) and H3-Board Schematic Diagram J-BOARD (1/4) TNPA3630AD (65PHD8BK/EK) TNPA3630AC (65PHD8UK) IC801 C0DBAMH00013 D_3.3V D_1.8V DIG12V AVR 9V 9V/0.5A R801 C807 C802 4.7u 470u L801 G1C470MA0078 R802 R808 C806 C809 2.2u 0.1u...
Page 204 IC2301 10W MONO BTL AMP R C1BA00000383 HP_IN HP_OUT C2362 HP-STB HP_D.C 470u R2351 SW_GND C2354 AMP-STB SW_GND R2353 Q2300 SW_B B1BBCF000028 SW_E L2330 JK8500 ON-TIME 220u L8501 SW_OUT K4BC02B00013 G0A2R5H00003 C2352 C2366 SPEAKER Vcc(SW) +R OUT C2412 2.2u C2360 TERMINAL PRE-GND 1000p...
Page 205: J-Board (2 Of 4) Schematic Diagram
15.17. J-Board (2 of 4) Schematic Diagram 3.3V STB3.3V R3125 SLOT1 C0JB SLOT2 SLOT3 SYNC S R8001 R3134 100k R8002 R8003 IC3008 R8004 C0JBAS000215 IIC ON/OFF PHD8UK ONLY SLOT1 C0JB SLOT2 SLOT3 SYNC S R8005 R8006 R8007 R8008 FL3006 SLOT9V F1J1E1040022 C8111 P-BOARD...
Page 206 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK IC8001 SLOT1 C0JBAR000241 C8003 C8035 SLOT2 R3163 Q8002 SLOT3 0.1u 0.1u SYNC SELECT(MAIN) 2SD0601A0L C8001 R8072 R8047 R8001 L8001 C8049 IC8007 R8036 G1C100K00020 C8027 R8002 R8009 R8035 0.01u R8010 C0JBAR000419 2.2u R8003 SYNC SWITCH(MAIN) R8004...
Page 207: J-Board (3 Of 4) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.18. J-Board (3 of 4) Schematic Diagram SYNC SIGNAL IC8003 PROCESSOR TPJH1 TPJV1 C1AA00000706 (MAIN) R8065 L8003 G1C100K00020 H.State Clamp Timing C8036 R8067 R8041 V.State V.Pol. 100p C8045 L8005 Green Sep Filter H.Pol. C8029 G1C100K00020...
Page 208 TPJH1 TPJV1 R8065 AG_HD_M AG_VD_M R8067 TPJH2 TPJV2 R8068 AF_HD_S AF_VD_S R8070 PHD8UK ONLY Q3101 C3002 L3003 2SD0601A0L G1C100K00020 Q8019 4.7u R3128 2SD0601A0L R3102 R8089 Q3102 R8057 R8069 R3129 R3103 2SD0601A0L Q3103 R3130 R3101 2SD0601A0L R3105 R3106 R3104 R8091 Q8018 R3199 2SD0601A0L R3131...
Page 209: J-Board (4 Of 4) Schematic Diagram
15.19. J-Board (4 of 4) Schematic Diagram IC8014 C0ZBZ0000911 STB3.3V RS232C DRIVER C8084 SHUTDOWN C8081 C8080 0.1u 0.1u AJ_TXD_4 T1_OUT AJ_RXD1 R8124 AJ_RXD_4 R1_IN C8082 AJ_TXD1 R8125 AJ_RXD4 0.1u R1_OUT R8126 ONLINE C8083 AJ_TXD4 T2_OUT T1_IN 0.1u R8127 R2_IN T2_IN R2_OUT STATUS IC3150...
Page 210 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK D-BOARD (D5) R3060 D3005 LNJ206R5ARA R3007 Q3004 R3023 2SD0601A0L D3007 MA2J11100L R3116 SLOT1 D-BOARD (D5) R3008 R3024 D3008 STB5V_S MA2J11100L LAN15V R8202 D8200 Q8202 MAZ31500ML SLOT2 2SD0601A0L R8203 C8200 D8201 R8204 Q8200 MA2J11100L 100k 2SD0601A0L...
Page 211: D-Board (1 Of 2) Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.20. D-Board (1 of 2) Block Diagram DIGITAL SIGNAL PROCESSOR FORMAT CONVERTER, PlASMA AI SUB-FIELD PROCESSOR TO J1 IC9002 IC9001 R(M) R/PR(M) P+5V G(M) 8bit A/D CONVERTER 3.3V G/Y(M) +3.3V B(M) R,G,B B/PB(M) MAIN VIDEO...
Page 212 1.2V 2.5V 3.3V R,G,B MAIN VIDEO 24bit 1.2V 2.5V 3.3V R,G,B SUB VIDEO 24bit TX0-3-(M) LVDS R,G,B R0-R7 TX0-3+(M) RECEIVER MAIN VIDEO G0-G7 TXC-(M) B0-B7 24bit Voltage TXC+(M) Differential R,G,B Signaling PICTURE R0-R7 TX0-3-(S) SUB VIDEO G0-G7 OUTPUT B0-B7 24bit TX0-3+(S) TXC-(S) PARALLEL...
Page 213: D-Board (2 Of 2) Block Diagram
15.21. D-Board (2 of 2) Block Diagram DIGITAL SIGNAL PROCESSOR FORMAT CONVERTER, PlASMA AI SUB-FIELD PROCESSOR IC9501 1.5V 2.5V 3.3V SIGNAL PROCESSOR FORMAT CONVERTER 1.5V 2.5V 3.3V R,G,B MAIN VIDEO 24bit R0-R9 DIGITAL PICTURE I/P ,FORMAT G0-G9 SIGNAL IMPROVER CONVERTER R,G,B SUB VIDEO 24bit B0-B9 PROCESSING...
Page 214 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK TO C24 DOUTU19A U19A-U21C IC9302 DOUTU21C 1.5V 2.5V 3.3V DRVRST PLASMA AI 3.3V SUB-FIELD PROCESSOR P+5V VIDEO DATA P+5V 1.5V 2.5V 3.3V Q9301 33bit(U8A-U15C,U19A-U21C) 5V DET DOUTU8A VIDEO DATA U8A-U15C 33bit(U0A-U7C,U16A-U18C) R0-R9 DOUTU15C PLASMA AI...
Page 215: D-Board (1 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.22. D-Board (1 of 12) Schematic Diagram D-BOARD (1/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) 12V->3.3V/1.4A 12V->1.5V/2.0A P12V C9780 220u FL9500 F1J1E1040022 R9593 R9596 R9595 8.2k 23.2k C9611 Q9502 Q9501 B1ABMD000004 0.01u B1MBCDA00002 CS1- C9646 INV1 CS1+ 16V 0.01u...
Page 216 FL9051 J0MAB0000175 ANF_R_S ANF_G_S J-BOARD EXPECT ANF_B_S (J1) PHD8UK R/PR_S PHD8UK ONLY R9028 PR_M G/Y_S R9029 ANF_R_M ANF_G_M G/Y_M ANF_B_M B/PB_S R9030 FL9001 3.3V J0MAB0000175 PHD8UK ONLY B/PB_M C9031 R9032 HD_S PHD8UK: 1.2k 0.1u R9031 Ex.UK:0 HD_S R9039 R9034 VD_S 1.2k R9033 PHD8UK:...
Page 217: D-Board (2 Of 12) Schematic Diagram
R9064 0.1u NRST R9016 R9066 NRST C9018 0.1u R9021 R9001 EXB2HVR000V R9002 EXB2HVR000V R9003 EXB2HVR000V AM_CLK R9171 DCK_M PHD8UK ONLY AS_CLK R9175 DCK_S R9179 D-BOARD (2/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) DG-BOARD TH-65PHD8 SERIES (8/12) D-Board (2 of 12) Schematic Diagram...
Page 218 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK PHD8UK ONLY C9069 C9070 R9073 6.3V 0.1u VOUT 3.3V R9054 C9071 C9056 6.3V 0.1u C9052 CBCBC00190 C9051 0.1u SA_B0 SA_B1 SA_B2 C9057 AVSS BOUT2 CLAMP DVDD 50V 0.01u SA_B3 R9057 AVDD AVDD DVDD BOUT3 SA_B4...
Page 219: D-Board (3 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.24. D-Board (3 of 12) Schematic Diagram FPGA FPGA_MODE VCCI 3.3V IC9201 IC9201 FPGA3.3V IC9201 L9204 IC9201 IC9201 IC9201 IC9201 IC9201 IC9201 C9225 C9201 IC9201 IC9201 6.3V IC9201 IC9201 IC9201 VCCO_7 C9202 IC9201 IC9201 IC9201 VCCO_6 0.1u...
Page 220 MAIN_B0 IC9201 IO_L21P_3 M_BOUT1 MAIN_B1 IC9201 IO_L21N_3 M_BOUT2 MAIN_B2 MAIN_B3 IC9201 IO_L24P_3 M_BOUT3 RD (3/12) MAIN_B4 IC9201 M_BOUT4 MAIN_B5 P01YUSE (TH-65PHD8BK/EK) MAIN_B6 IC9201 IO_L16P_3 M_BOUT5 MAIN_B7 IC9201 IO_L19P_3 M_BOUT6 P020YUS (TH-65PHD8UK) IC9201 IO_L19N_3 M_BOUT7 VDO_M IC9201 IO_L16N_3 VDOA R9274 HDO_M...
Page 221: D-Board (4 Of 12) Schematic Diagram
15.25. D-Board (4 of 12) Schematic Diagram IC9103 C0JBAE000354 2.5V->3.3V 3.3V LEVEL CONVERTER C9108 3.3V 0.1u L9502 C9654 G1C150KA0038 6.3V R9611 4.7k TDO_2V C9650 TDO_57 0.1u R9149 2.5V_3 TDI_57 C9107 0.1u R9636 C9652 TCK_BS DD_ODEU TCK_2V DD_ODED TMS_BS FP_NUEL TMS_2V C9653 FP_UMH TDO_TED...
Page 222 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK D-BOARD (4/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) IC9304 IC9305 IC9306 C0JBAZ000856 C0JBAZ000856 C0JBAZ000856 3.3V->5V 3.3V->5V LEVEL CONVERTER LEVEL CONVERTER 3.3V->5V LEVEL CONVERTER C9462 C9461 C9463 _ODEU FP_DSHR _ODED D-ODEU FP_DSLR DD_PCU1 _NUEL D-ODED FP_DMHR DD_PCU2 D-PCU1...
Page 223: D-Board (5 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.26. D-Board (5 of 12) Schematic Diagram D-BOARD (5/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) FL9502 3.3V 3.3V_L78 F1J1E1040022 C9764 220u DDR I/F DDR-TERMINATE L7_DQ31 L7_ADRS11 IC9501 DQ31 IC9501 ADRS11 R9741 R9859 L7_DQ30 L7_ADRS10 EXB2HV330JV EXB2HV330JV IC9501...
Page 224 FL9305 FL9304 POWER 2.5V_L8 1.5V 1.5V_L8 2.5V_2 F1J1E1040022 F1J1E1040022 C9441 220u 3.3V_L78 C9387 IC9302 IC9302 IC9302 VDD33 16V 0.1u C9388 IC9302 IC9302 IC9302 VDD33 16V 0.1u C9389 IC9302 IC9302 IC9302 VDD33 16V 0.1u C9390 IC9302 IC9302 IC9302 VDD33 16V 0.1u C9391 IC9302 IC9302...
Page 225: D-Board (6 Of 12) Schematic Diagram
PLASMA AI L8_DQ1 IC9302 SUB-FIELD PROCESSOR L8_DQ0 IC9302 2.5V_L8 R9493 1.1k IC9302 AB14 C9425 R9494 3.16k 0.1u 2.5V_L8 R9495 IC9302 AC16 C9442 R9496 0.1u D-BOARD (6/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) DG-BOARD TH-65PHD8 SERIES (12/12) D-Board (6 of 12) Schematic Diagram...
Page 226 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK L-UP TERM C2-BOARD (C25) FL9301 F1J1E1040022 TP9343 TP9342 3.3V 3.3V R9476 D9302 MA3X152K0L D9303 R9480 MA3X152K0L R9477 C9443 Q9301 4.7k R9478 Q9300 R9482 100k C9444 0.01u 4.7k R9484 B1ABCF000138 B1ABCF000138 100k 0.01u ZA007 ZA001 K4CD01000013...
Page 227: D-Board (7 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.28. D-Board (7 of 12) Schematic Diagram DG-BOARD (1/12) P12V J-BOARD (J3) R9995 FL9707 STB5V_M F1J1E1040022 Q9078 R9986 B1ABCF000138 STB3.3V R9881 STB5V AR_IIC_CONT IIC_CONT R9882 EXB38VR000V 3V_SCL1 SCL1 3V_SDA1 SDA1 5V_SCL3 SCL3 5V_SDA3 SDA3 N.C.
Page 228 D-BOARD (7/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) P12V R9995 R9993 Q9078 R9986 B1ABCF000138 5V_SCL3 3V_SCL3 P12V R9479 R9992 Q9951 B1ABCF000138 5V_SDA3 3V_SDA3 R9991 R9481 STB3.3V STB5V FACTORY FL9701 R9844 STB3.3V F1J1E1040022 5.6k R9845 TP9701 AR_IIC_CONT R9843 C9604 STB3.3V 100p AR_IIC_CONT TP9702...
Page 229: D-Board (8 Of 12) Schematic Diagram
15.29. D-Board (8 of 12) Schematic Diagram D-BOARD (8/12) DG-BOARD (2/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) D9707 C9726 MA2J72800L 1000p STB3.3V R9810 C9594 R9826 0.1u R9701 Q9707 B1ABCF000138 R9828 AA_REMOCON R9829 R9827 P65/A06 R9834 P67/A08 P64/A05 P84/A21 OSCMD0 P63/A04 P62/A03 R9833...
Page 230 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK DG-BOARD (2/12) D9707 R9808 C9726 MA2J72800L 1000p STB3.3V C9709 0.1u 9810 R9805 AAE_MCCLK R9803 R9785 AAE_MCDATA_O 3.3V R9797 SDA2 R9801 P65/A06 PC4/SDA1 P67/A08 P51/OE 120 CPUMD0 SCL2 R9798 P64/A05 P84/A21 P52/WE PC5/SCL1 119 CPUMD1 R9795...
Page 231: D-Board (9 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.30. D-Board (9 of 12) Schematic Diagram SYNC R9240 L8_VOUT IC9201 IO_L17P_3/VREF_3 XNVD L7_HOUT IC9201 IO_L17N_3 XNHD R9241 AM_VD IC9201 IO_L40N_6 VDIAA R9242 AM_HD IC9201 IO_L40P_6/VREF_6 R9243 HDIAA AM_CLK IC9201 IO_L32N_5/GCLK3 FPGA R9244 DCKA R9245...
Page 232 O_L39P_3 LATCH VDO_S O_L24N_3 SFVRST IC9201 VDOB R9280 HDO_S O_L22P_3 SFRST IC9201 IO_L31P_5/D5 HDOB R9281 DCK_S DCKBO FPDATA1 IC9201 IO_L31N_5/D4 R9282 O_L22N_3 FPDATA0 OUTPUT_SUB O_L40P_3 FPCLK D-BOARD (9/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) TH-65PHD8 SERIES D-Board (9 of 12) Schematic Diagram...
Page 233: D-Board (10 Of 12) Schematic Diagram
15.31. D-Board (10 of 12) Schematic Diagram 1.5V_L7 C9662 IC9501 VDD15 16V 0.1u C9663 IC9501 VDD15 16V 0.1u C9664 IC9501 VDD15 16V 0.1u C9665 IC9501 IC9501 IC9501 VDD15 16V 0.1u C9666 IC9501 IC9501 IC9501 VDD15 16V 0.1u C9667 IC9501 IC9501 IC9501 VDD15 16V 0.1u...
Page 234 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK D-BOARD (10/12) DG-BOARD (4/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) 1.5V_L7 IC9501 VDD15 IC9501 VDD15 IC9501 VDD15 IC9501 VDD15 IC9501 VDD15 IC9501 IC9501 VDD15 MN845111-A IC9501 VDD15 MAIN_R7 SUB_R7 IC9501 RVIA7 IC9501 RVIB7 SIGNAL PROCESSOR IC9501 VDD15...
Page 235: D-Board (11 Of 12) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.32. D-Board (11 of 12) Schematic Diagram IC9501 MN845111-A SIGNAL PROCESSOR 3.3V FORMAT CONVERTER L7_ROUT9 DDR-SDRAM IC9501 ROUT9 C9758 L7_ROUT8 IC9501 ROUT8 0.1u L7_ROUT7 IC9501 ROUT7 2.5V_L7 L7_ROUT6 IC9501 ROUT6 L7_ROUT5 IC9501 ROUT5 L7_ROUT4 R9622...
Page 236 D-BOARD (11/12) DG-BOARD (5/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) IC9302 TIOCTL0 L8_R0 L8_PCK IC9302 IC9302 IC9302 TIOCTL1 L8_R1 IC9302 3.3V IC9302 TCKSEL0 3.3V_L78 L8_R2 IC9302 IC9302 TCPOUT IC9302 TCKSEL1 R9413 L8_R3 IC9302 IC9302 TCKSEL2 IC9302 PLLON R9644 L8_R4 4.7k IC9302 L8_G5...
Page 237: D-Board (12 Of 12) Schematic Diagram
15.33. D-Board (12 of 12) Schematic Diagram D-BOARD (12/12) DG-BOARD (6/12) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) IC9302 MN845121-A PLASMA AI SUB-FIELD PROCESSOR DRVCLKD0 L8DO_DA0 L8DO_DB0 IC9302 DRVCLKD0 IC9302 DOUTDA00 IC9302 DOUTDB00 DRVCLKD1 L8DO_DA1 L8DO_DB1 IC9302 DRVCLKD1 IC9302 DOUTDA01 IC9302 DOUTDB01 DRVCLKD2...
Page 238 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK DG-BOARD (6/12) DDR-SDRAM C9439 0.1u 2.5V_L8 R9497 R9498 L8DO_DC0 IC9302 DOUTDB00 IC9302 DOUTDC00 L8DO_DC1 IC9302 DOUTDB01 IC9302 DOUTDC01 L8DO_DC2 IC9302 DOUTDB02 IC9302 DOUTDC02 L8DO_DC3 IC9302 DOUTDB03 IC9302 DOUTDC03 L8DR_DQ29 L8DR_AD7 L8DO_DC4 L8DR_AD6 IC9302 DOUTDB04 IC9302...
Page 239: C1, C2, C5 And C6-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.34. C1, C2, C5 and C6-Board Block Diagram 26,36 16,25 R7187 DATA DATA 24bit 24bit R7186 U14A DATA DRIVE U14A U21C U21C UPPER-RIGHT(FRONT VIEW) PCU2 PCU2 P+5V 6bit 6bit 6bit 6bit 6bit IC7208 IC7202 IC7106...
Page 240 48-29,20-15 U0A-U7C PCU2 P+5V 18bit 6bit 6bit 6bit BUFFER IC7202 IC7201 IC7203 IC7204 IC7205 IC7206 BUFFER BUFFER BUFFER BUFFER U14A U16A U18A IC7207 8A-9C 12A-13C 10A-11C U15C U17C U19C 6bit 6bit 6bit Vda75V D7201 D7202 D7203 D7104 D7205 D7206 +78V_L LEU/CLK DRIVE R-CENTER(FRONT VIEW)
Page 241: C2, C3, C4 And C5-Board Block Diagram
15.35. C2, C3, C4 and C5-Board Block Diagram U4A-U7C U4A-U7C IC7209, IC7210 12bit U0A-U7C 12bit BUFFER DRVRST P+5V U2A-U3C U2A-U3C 6bit IC7211 6bit LEU,PCU1 LEU,PCU1 BUFFER U0A-U1C U0A-U1C 6bit IC7212 6bit CLKU0,CLKU1 CLKU0,CLKU1 BUFFER Vda75V +78V-R +78V_L C2 DATA DRIVE UPPER CENTER(FRONT VIEW 68 64 52 51...
Page 242 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK DATA DRIVE R7386 DATA 24bit UPPER LEFT(FRONT VIEW) R7387 6bit 6bit 6bit 6bit IC7305 IC7301 IC7302 IC7304 IC7303 BUFFER BUFFER BUFFER BUFFER BUFFER SS35 PCU1 6A-7C 4A-5C 2A-3C 0A-1C Vda75V 6bit 6bit 6bit 6bit D7306...
Page 243: C1-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.36. C1-Board (1 of 2) Schematic Diagram C1-BOARD TNPA3663 (1/2) ZA7101 ZA7102 ZA7103 ZA7104 K4CD01000013 K4CD01000013 K4CD01000013 K4CD01000013 L7101 L7102 J0JJC0000011 J0JJC0000011 R7111 R7115 TERM PANEL DATA DRIVER R7101 L710 J0JJC000 R7109 R7113 C7101 TERM...
Page 244 D7101 VDA_75V B0HCMM000014 C7107 100V 0.47u D7102 B0HCMM000014 L7101 L7102 78V_R J0JJC0000011 J0JJC0000011 C7102 C1_5V C7150 100p VDA_75V D7103 B0HCMM000014 C7103 100V 0.47u D7104 B0HCMM000014 78V_R L7103 L7104 J0JJC0000011 J0JJC0000011 R7113 C1_5V C7152 100p TH-65PHD8 SERIES C1-Board (1 of 2) Schematic Diagram...
Page 245: C1-Board (2 Of 2) Schematic Diagram
15.37. C1-Board (2 of 2) Schematic Diagram C1-BOARD TNPA3663 (2/2) VDA_75V D7107 B0HCMM000014 C7104 100V 0.47u D7108 B0HCMM000014 L7105 L7106 78V_R J0JJC0000011 J0JJC0000011 R7127 R7131 C1_5V TERM PANEL DATA DRIVER C7111 100p VDA_75V D7105 B0HCMM000014 C7155 100V 0.47u D7106 B0HCMM000014 L7107 L7108 J0JJC0000011...
Page 246 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK R7173 R7174 EXB38V681JV EXB38V681JV C1_5_3V BUFFER 78V_R C7169 78V_R 78.0 0.1u VDA_75V AA_DUC15 AA_DUB15 Vda 75V AB_DUC15 75.0 AA_DUA15 AB_DUB15 AB_DUA15 AA_DUC14 AB_DUC14 AA_DUB14 R7126 EXB38V470JV AA_DUA14 AB_DUB14 C2-BOARD AB_DUA14 (C22) R7128 EXB38V470JV C1_5V C1_5_3V...
Page 247: C2-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.38. C2-Board (1 of 2) Schematic Diagram C2-BOARD TNPA3664 (1/2) C2_5_3V R7253 EXB38V681JV R7252 C7274 EXB38V681JV 0.1u AA_DUC15 AA_DUB15 AB_DUC15 AA_DUA15 AB_DUB15 AB_DUA15 AA_DUC14 78V_R AB_DUC14 AA_DUB14 78V_R R7290 78.0 EXB38V470JV AA_DUA14 VDA_75V AB_DUB14 AA_CLR_R...
Page 248 D7201 VDA_75V B0HCMM000014 C7232 100V 0.47u D7202 B0HCMM000014 L7203 L7204 78V_L J0JJC0000011 J0JJC0000011 R7263 R7227 R7230 C7203 C2_5V PANEL DATA DRIVER TERM C7238 100p R7254 R7255 EXB38V681JV EXB38V681JV C2_5_3V R7710 C2_5_3V_B C7208 16V 0.1u BUFFER R7212 R7213 DRST BUFFER C7216 R7276 0.1u CLKCEN...
Page 249: C2-Board (2 Of 2) Schematic Diagram
15.39. C2-Board (2 of 2) Schematic Diagram C2-BOARD TNPA3664 (2/2) VDA_75V D7205 B0HCMM000014 C7234 100V 0.47u D7206 B0HCMM000014 L7207 L7208 78V_L J0JJC0000011 J0JJC0000011 R7262 R7266 C7224 C2_5V TERM PANEL DATA DRIVER VDA_75V D7203 C7240 B0HCMM000014 100p C7235 78V_L 100V 0.47u D7204 B0HCMM000014 L7206...
Page 250 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK R7284 R7285 C2_5_3V EXB38V681JV EXB38V681JV BUFFER C7214 0.1u AA_DUC7 AA_DUB7 AB_DUC7 AA_DUA7 AB_DUB7 AB_DUA7 78V_L AA_DUC6 AB_DUC6 AA_DUB6 R7286 EXB38V470JV AA_DUA6 D7209 B0HDSM000005 78V_R AB_DUB6 78V_L 78.0 AB_DUA6 78V_R 78.0 VDA_75V R7287 Vda 75V EXB38V470JV 75.0...
Page 251: C3-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.40. C3-Board (1 of 2) Schematic Diagram R7392 R7393 EXB38V681JV EXB38V681JV C3_5_3V C3-BOARD TNPA3665 (1/2) BUFFER C7308 0.1u AA_DUC7 AA_DUB7 AB_DUC7 AA_DUA7 AB_DUB7 AB_DUA7 AA_DUC6 AB_DUC6 AA_DUB6 R7303 EXB38V470JV AA_DUA6 AB_DUB6 AA_ODE_L AB_DUA6 AA_CLR_L AB_ODE_L...
Page 252 VDA_75V D7303 B0HCMM000014 C7359 100V D7304 0.47u B0HCMM000014 L7301 L7302 J0JJC0000011 J0JJC0000011 78V_L R7361 R7365 R7355 R7367 PANEL DATA DRIVER C7326 100p VDA_75V D7301 B0HCMM000014 C7360 100V 0.47u D7302 B0HCMM000014 78V_L L7303 L7304 J0JJC0000011 J0JJC0000011 R7360 R7364 C3_5V C7315 R7354 R7366 C7323 100p...
Page 253: C3-Board (2 Of 2) Schematic Diagram
15.41. C3-Board (2 of 2) Schematic Diagram C3-BOARD TNPA3665 (2/2) VDA_75V D7305 B0HCMM000014 C7361 100V D7306 0.47u B0HCMM000014 78V_L L7305 L7306 J0JJC0000011 J0JJC0000011 R7378 R7382 CA10 TERM R7384 R7374 PANEL DATA DRIVER C7351 100p VDA_75V D7307 B0HCMM000014 C7362 100V 0.47u D7308 B0HCMM000014 L7307...
Page 254 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK C3_5V C7340 C3_5V C7339 R7385 TH-65PHD8 SERIES C3-Board (2 of 2) Schematic Diagram...
Page 255: C4-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.42. C4-Board (1 of 2) Schematic Diagram C4-BOARD TNPA3666 (1/2) R7447 C4_5_3V_B C7406 0.1u NUEL CLKL NUEL DRV_SOS9 CLK11 DRV_SOS9 R7405 DRV_SOS2 NCLKL CLK12 DRV_SOS2 R7406 DMHR CLK21 DMHR R7407 DMLL CLK22 DMLL R7408 DMHL...
Page 256 VDA_75V D7407 C7420 B0HCMM000014 100V 0.47u D7408 B0HCMM000014 L7401 L7402 78V_L J0JJC0000011 J0JJC0000011 R7464 R7468 C4_5V C7418 R7460 C7428 100p VDA_75V D7405 C7421 B0HCMM000014 100V 0.47u D7406 B0HCMM000014 L7403 L7404 R7465 R7469 J0JJC0000011 J0JJC0000011 78V_L C4_5V C7419 R7471 R7461 C7429 100p TH-65PHD8 SERIES C4-Board (1 of 2) Schematic Diagram...
Page 257: C4-Board (2 Of 2) Schematic Diagram
15.43. C4-Board (2 of 2) Schematic Diagram C4-BOARD TNPA3666 (2/2) ZA7401 ZA7402 ZA7403 ZA7404 K4CD01000013 K4CD01000013 K4CD01000013 K4CD01000013 VDA_75V D7411 B0HCMM000014 C7422 100V 0.47u D7412 B0HCMM000014 L7405 78V_L L7406 J0JJC0000011 J0JJC0000011 R7481 R7485 C4_5V CB11 TERM R7472 PANEL DATA DRIVER R7477 R7487 C7453...
Page 258 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK SS-BOARD (SS44) C4_5V NC(URH) NUEL NUEL C7440 DRV_SOS9 DRV_SOS9 NC(URL) DMHR_BUF DMHR DSHL_BUF DSHL DSLL_BUF DSLL DMHL_BUF DMHL DMLL_BUF DMLL DRV_SOS2 DRV_SOS2 78V_R 78V_L VDA_75V C4_5V C7441 SS-BOARD (SS42) TH-65PHD8 SERIES C4-Board (2 of 2) Schematic Diagram...
Page 259: C5-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.44. C5-Board (1 of 2) Schematic Diagram C5-BOARD TNPA3667 (1/2) TERM C6-BOARD (C60) R7511 R7512 EXB38V681JV EXB38V681JV AB_DDC20 C5_5_3V DOUTDC[20] AB_DDB20 BUFFER DOUTDB[20] AB_DDA20 C7558 DOUTDA[20] 0.1u AB_DDC21 DOUTDC[21] AA_DDA15 AB_DDB21 DOUTDB[21] AA_DDB15 AB_DDA21 AB_DDA15...
Page 260 D-BOARD (D34) C5_5V FL7501 J0HABH000013 R7565 R7564 EXB38V681JV EXB38V681JV C5_5_3V_B C5_5_3V R7539 BUFFER BUFFER C7505 C7507 0.1u 0.1u AA_DDA13 CLKCEN AA_DDB13 AB_DDA13 R7572 NCLKCEN CLKL1 AA_DDC13 AB_DDB13 R7578 R7573 R7551 CLKL2 AB_DDC13 R7550 AA_DDA12 R7579 AB_DDA12 R7552 AA_DDB12 R7584 R7533 R7553 EXB38V470JV AA_DDC12...
Page 261: C5-Board (2 Of 2) Schematic Diagram
15.45. C5-Board (2 of 2) Schematic Diagram TERM C5_5V FL7502 J0HABH000013 R7568 R7569 R7566 R7567 EXB38V681JV EXB38V681JV EXB38V681JV EXB38V681JV C5_5_3V C5_5_3V BUFFER BUFFER C7514 C7512 0.1u 0.1u AA_DDA11 AA_DDA9 AA_DDB11 AA_DDB9 AB_DDA11 AB_DDA9 AA_DDC11 AB_DDB11 AA_DDC9 AB_DDB9 AB_DDC11 AB_DDC9 AA_DDA10 AA_DDA8 AB_DDA10 AB_DDA8...
Page 262 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK C5-BOARD TNPA3667 (2/2) D-BOARD (D33) R7616 R7617 C5_5_3V EXB38V681JV EXB38V681JV BUFFER C7567 0.1u UEH_BUF USL_BUF UML_BUF R7618 EXB38V470JV NUEL UMH_BUF NUEL_BUF R7619 EXB38V470JV C4-BOARD (C41) R7613 R7517 R7518 UEH_BUF EXB38V681JV EXB38V681JV C5_5_3V USL_BUF BUFFER USH_BUF C7560 0.1u...
Page 263: C6-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.46. C6-Board (1 of 2) Schematic Diagram C6-BOARD TNPA3668 (1/2) ZA7602 ZA7601 K4CD01000013 K4CD01000013 C7602 TERM PANEL DATA DRIVER R7607 TERM R7604 PANEL DATA DRIVER TH-65PHD8 SERIES C6-Board (1 of 2) Schematic Diagram...
Page 264 VDA_75V D7601 B0HCMM000014 C7653 100V 0.47u D7602 B0HCMM000014 L7601 L7602 R7611 R7615 J0JJC0000011 78V_R J0JJC0000011 C6_5V R7617 C7612 100p VDA_75V D7603 B0HCMM000014 C7654 100V 0.47u D7604 B0HCMM000014 R7609 R7613 L7603 L7604 78V_R J0JJC0000011 J0JJC0000011 C6_5V C7601 R7605 R7616 C7611 100p TH-65PHD8 SERIES C6-Board (1 of 2) Schematic Diagram...
Page 265: C6-Board (2 Of 2) Schematic Diagram
15.47. C6-Board (2 of 2) Schematic Diagram C6-BOARD TNPA3668 (2/2) VDA_75V D7607 B0HCMM000014 C7695 100V 0.47u D7608 B0HCMM000014 R7658 R7660 L7607 L7608 78V_R J0JJC0000011 J0JJC0000011 C6_5V C7687 TERM PANEL DATA DRIVER R7666 R7661 R7656 C7688 100p VDA_75V D7605 B0HCMM000014 C7655 100V 0.47u D7606...
Page 266 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK C5-BOARD (C50) R7681 BUFFER C6_5_3V_B C7630 0.1u CLKR CLK11 R7643 NCLKR CLK12 R7644 CLK21 R7645 CLK22 R7646 R7601 R7602 R7672 R7647 AA_DDC20 R7648 DOUTDC[20] AA_DDB20 R7649 DOUTDB[20] AA_DDA20 R7671 DOUTDA[20] AA_DDC21 DOUTDC[21] AA_DDB21 DOUTDB[21] AA_DDA21...
Page 267: Sc, Su And Sd-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.48. SC, SU and SD-Board Block Diagram TPVSET SC SCAN DRIVE COLD FLOATING GND TPVSUS TO P2 VSET Gen. Vsus IC6654 IC6653 IC6652 TPVSET (+230V) +5V(SC1) +5V(SC2) +15V(SC1) IC6812 +5V(SC1) +20V D6518 Q6577,Q6814 +15V (SC1)
Page 268 SU SCAN OUT (UPPER) TPSC1 WAVEFORM VSET PDP SCAN DRIVERx6 VSUS VDDH D6902 IC6900 +20V LINE FSIU FSIU VSCN 64bit FCLU VSET2 FCLU FCLKU FCLKU VDDH PROU IC6901 PROU Vf+5V Vf+5V VSCN,VAD D6839 64bit SOSDET D6837 VSCN-VAD<14V:ON SC41 SU41 VDDH Q6825,D6838 (Vf5V) IC6902...
Page 269: Sc-Board (1 Of 3) Schematic Diagram
15.49. SC-Board (1 of 3) Schematic Diagram TPVSUS R6375 C6502 C6504 C6503 P-BOARD 250V 250V 250V (P2) 2.2u 2.2u 2.2u L6414 R6376 182.0 G0ZZ00002183 Vsus G0ZZ C6401 C6402 C6403 C6404 C6405 C6406 C6407 C6408 C6409 R6811 R6377 200V 200V 200V 200V 200V 200V...
Page 270 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK S2(CMH) VSUS Q6551 C6502 C6504 C6506 C6509 C6503 C6507 C6508 C6510 250V 250V 250V 250V 250V 250V 250V 250V Q6501 B1ABNF000006 R6501 10 2.2u 2.2u 2.2u 2.2u 2.2u 2.2u 2.2u 2.2u B1JADN000002 C6511 630V R6502 10...
Page 271: Sc-Board (2 Of 3) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.50. SC-Board (2 of 3) Schematic Diagram Q6814 D6813 R6827 D1FL40 2SD1263AP0LB D6831 D6814 C6812 C6813 C6814 C6815 MA2J11100L R6886 R6831 R6807 630V 630V 630V 3300p D1FL40 220k 100k 3300p 3300p 3300p R6829 630V 100k...
Page 272 TP061 COLD FLOATING GND C6821 D6818 L6814 220u D1FS6 J0JJC0000021 C6818 R6877 R6837 180k 0.01u 100k C6807 C6820 R6842 6841 R6839 R6840 R6841 3 NC HCMM000014 50V 4700p 154k 2.2k C6822 220u R6845 2.2k R6843 0.1u D6817 MA111 R6838 3.3k IC6814 T6802 L6810...
Page 273: Sc-Board (3 Of 3) Schematic Diagram
15.51. SC-Board (3 of 3) Schematic Diagram SU-BOARD SU-BOARD SC41 (SU41) SC42 (SU42) ZA6401 K4CD01000013 SU-BOARD ZA6402 (SU45) K4CD01000013 TP032 AA_FSIU AA_FSIU ZA6403 K4CD01000013 TP033 AA_FCLU TP034 AA_FCLU AA_FCLKU VF+5V TP035 AA_PROU AA_FCLKU 5V_F TP036 AA_PROU (Vscn Voltage) TP037 TP044 TP045 TP046 TP047...
Page 274 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK SD-BOARD SD-BOARD SC43 SC44 (SD43) (SD44) Vfo(Vscn Out) (Vscn Voltage) TP049 TP050 TP051 TP052 TP053 TP043 5V_F VF+5V TP042 TP041 AA_PROD AA_PROD TP040 AA_FCLKD TP039 AA_FCLD AA_FCLKD TP038 AA_FSID AA_FCLD AA_FSID SD-BOARD (SD46) TH-65PHD8 SERIES...
Page 275: Su-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.52. SU-Board (1 of 2) Schematic Diagram SU-BOARD TNPA3673 (1/2) To 1st 96pins of To 2nd 96pins of SCAN ELECTRODES SCAN ELECTRODES AF_27 AF_38 AE_91 AE_102 AD_155 AF_26 AF_39 AE_90 AE_103 AD_154 AF_25 AF_40 AE_89...
Page 276 AD_155 AD_166 AD_154 AD_167 AD_153 AD_168 AD_152 AD_169 OUT41 OUT24 OUT35 OUT30 AD_151 AD_170 OUT42 OUT36 OUT29 OUT23 AD_150 AD_171 OUT37 OUT28 OUT43 OUT22 AD_149 AD_172 IC6902 OUT44 OUT21 AD_148 AD_173 OUT45 OUT20 AD_147 AD_174 AN16021A-VT OUT46 OUT19 AD_146 AD_175 OUT47 OUT18 AD_145...
Page 277: Su-Board (2 Of 2) Schematic Diagram
15.53. SU-Board (2 of 2) Schematic Diagram SU-BOARD TNPA3673 (2/2) To 3rd 96pins of SCAN ELECTRODES AC_219 AC_230 AB_283 AC_218 AC_231 AB_282 AC_217 AC_232 AB_281 AC_216 AC_233 AB_280 OUT41 OUT24 OUT41 OUT35 OUT30 OUT35 AC_215 AC_234 AB_279 OUT42 OUT36 OUT29 OUT23 OUT42 OUT36...
Page 278 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK To 4th 96pins of SCAN ELECTRODES AB_294 AA_347 AA_358 AB_295 AA_346 AA_359 AB_296 AA_345 AA_360 AB_297 AA_344 AA_361 OUT24 OUT41 OUT24 OUT35 OUT30 OUT35 OUT30 AB_298 AA_343 AA_362 OUT36 OUT29 OUT23 OUT42 OUT36 OUT29 OUT23...
Page 279: Sd-Board (1 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.54. SD-Board (1 of 2) Schematic Diagram SD-BOARD TNPA3674 (1/2) To 1st 96pins of To 2nd 96pins of SCAN ELECTRODES SCAN ELECTRODES AF_411 AF_422 AE_475 AE_486 AF_410 AF_423 AE_474 AE_487 AF_409 AF_424 AE_473 AE_488 AF_408...
Page 280 96pins of ELECTRODES AE_486 AD_539 AD_550 AE_487 AD_538 AD_551 AE_488 AD_537 AD_552 AE_489 AD_536 AD_553 OUT24 OUT41 OUT24 OUT35 OUT30 AE_490 AD_535 AD_554 OUT23 OUT42 OUT36 OUT29 OUT23 AE_491 AD_534 AD_555 OUT37 OUT28 OUT22 OUT43 OUT22 AE_492 AD_533 AD_556 OUT21 OUT44 IC6922 OUT21...
Page 281: Sd-Board (2 Of 2) Schematic Diagram
15.55. SD-Board (2 of 2) Schematic Diagram SD-BOARD TNPA3674 (2/2) To 3rd 96pins of SCAN ELECTRODES AC_603 AC_614 AB_667 AC_602 AC_615 AB_666 AC_601 AC_616 AB_665 AC_600 AC_617 AB_664 OUT41 OUT24 OUT41 OUT35 OUT30 OUT35 OUT30 AC_599 AC_618 AB_663 OUT42 OUT36 OUT29 OUT23 OUT42...
Page 282 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK To 4th 96pins of SCAN ELECTRODES AB_678 AA_731 AA_742 AB_679 AA_730 AA_743 AB_680 AA_729 AA_744 AB_681 AA_728 AA_745 OUT24 OUT41 OUT24 OUT30 OUT35 OUT30 AB_682 AA_727 AA_746 OUT29 OUT23 OUT42 OUT36 OUT29 OUT23 AB_683 AA_726...
Page 283: Ss, S1, Ss2 And Ss3-Board Block Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.56. SS, S1, SS2 and SS3-Board Block Diagram TO C44 VE Gen. SUSTAIN DRIVE TPVE (+150 VR6250 IC6060 Q6256,Q625 BUFFER TPSOS2 IC625 TPVSUS TO P1 Vsus Q6118-Q Q6160-Q Vsus Gen. Q6100-Q Q6140-Q IC6100 FET DRIVER...
Page 284 SS51 VE Gen. TPVE (+150V) TPVe VR6250 Adj. D6257 SS52 Q6256,Q6257 IC6252 SS23 Q6118-Q6121 Q6160-Q6163 Q6100-Q6105 SS25 Q6140-Q6145 C6100 OUTPUT ET DRIVER Y RECOVERY Q6000-Q6002 L6010-13 Q6020-Q6022 C6000 L6015,16 C6020 OUTPUT L6030 L6031 L6033 SS53 T DRIVER L6034 D6063 LED(G) TPSS1 IC6061 COMPARATOR...
Page 285 15.57. SS-Board (1 of 2), S1, SS2 and SS3-Board Schematic Diagram SS-BOARD TNPA3670 (1/2) TPVSUS L6170 P-BOARD D6000 G0ZZ00002183 L6040 RF2001T3D (P11) G0ZZ00002183 182.1 VSUS L6042 C6173 C6170 C6171 C6172 C6174 C6175 C6176 C6177 C6178 G0ZZ00002183 200V 200V 200V 200V 200V 200V 200V...
Page 286 TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK SS53 Q6100 B1JADN000002 R6100 C6080 C6100 250V 2.2u 630V 5600p R6101 R6139 R6138 R6137 R6136 Q6118 C6081 B1ABNF000006 R6102 250V Q6101 2.2u B1JADN000002 SS2-BOARD C6082 D6135 250V MA2J11100L TNPA3671 2.2u PANEL R6103 SUSTAIN C6083 Q6102...
Page 287: Ss-Board (2 Of 2) Schematic Diagram
TH-65PHD8BK / TH-65PHD8EK / TH-65PHD8UK 15.58. SS-Board (2 of 2) Schematic Diagram C6202 470u L6223 J0JJC0000021 D6206 D1FL40 Vda_75V Q6007 Q6200 2SB792ATX R6210 R6245 Q6210 2SK326900L 5.9k B1ABNF000006 D6240 R6053 DF20LC20U R6243 R6200 D6241 C6114 D1FL40 D6242 R6212 D1FL40 R6211 R6054 150 4.7u...
Page 288 C6207 C6206 160V 160V Vda_75V 100u 100u Q6200 R6219 2SK326900L 100k R6192 R6193 150k R6240 71.5k JS6201 R6241 10.7k L6205 D6215 G0CR60KA0118 TP6916 DF20LC20U 78.0 R6242 VDAR L6206 C6210 L6236 4.99k 250V 78.0 G0CR60KA0118 J0JJC0000021 2.2u VDAR C6211 L6207 250V D6226 2.2u G0CR60KA0118...
Page 289 INPUT Equipment Setting Alignment menu Procedure Note: · Before adjustment, color signal has not been displayed 1 PC (VGA) Color Picture menu: on panel. Gray Scale Analyzer Standard · The pedestal adjustment has been done. Pattern Picture: · The signal root must be A side. PANEL W/B G cut off 1) Set G cut off to "...
Page 290 Color temperature High A0-11AD A0-11AE A0-11AF Medium A0-11B0 A0-11B1 A0-11B2 A0-11B3 A0-11B4 A0-11B5 Table 2 Drive data addresses (PC/RGB) Color temperature High A0-1180 A0-1181 A0-1182 Medium A0-1183 A0-1184 A0-1185 A0-1186 A0-1187 A0-1188 Table 3 Drive data addresses (NTSC) Color temperature High A0-1189 A0-118A...
Page 291 INPUT Equipment Setting Alignment menu Procedure Note: · Before adjustment, color signal has not been displayed Color Picture menu: on panel. (YUV2_HD) Analyzer Standard · The pedestal adjustment has been done. Gray Scale Picture: · The signal root must be A side. PANEL W/B Pattern G cut off...
Page 292 Color temperature High A0-119B A0-119C A0-119D Medium A0-119E A0-119F A0-11A0 A0-11A1 A0-11A2 A0-11A3 Table 2 Drive data addresses (YUV2_HD) Color temperature High A0-1192 A0-1193 A0-1194 Medium A0-1195 A0-1196 A0-1197 A0-1198 A0-1199 A0-119A Table 3 Drive data addresses (YUV1_525ip) Color temperature High A0-11A4 A0-11A5...
Page 293 26,36 48-29,20-15 16,25 R7187 DATA DATA 24bit U0A-U7C 24bit R7186 U14A DATA DRIVE U14A U21C U21C UPPER-RIGHT(FRONT VIEW) PCU2 PCU2 P+5V P+5V 6bit 18bit 6bit 6bit 6bit 6bit 6bit 6bit 6bit IC7208 BUFFER IC7202 IC7106 IC7105 IC7104 IC7107 IC7102 BUFFER IC7201 IC7203 IC7204...
Page 294 U4A-U7C U4A-U7C IC7209, IC7210 12bit U0A-U7C 12bit DATA DRIVE R7386 DATA BUFFER 24bit UPPER LEFT(FRONT VIEW) R7387 DRVRST P+5V U2A-U3C U2A-U3C IC7211 6bit 6bit 6bit 6bit 6bit 6bit LEU,PCU1 LEU,PCU1 BUFFER IC7305 IC7301 IC7302 IC7304 IC7303 BUFFER U0A-U1C U0A-U1C BUFFER BUFFER BUFFER 6bit...
Page 295 DIGITAL SIGNAL PROCESSOR FORMAT CONVERTER, PlASMA AI SUB-FIELD PROCESSOR TO J1 IC9002 IC9001 R(M) R/PR(M) P+5V G(M) 8bit A/D CONVERTER 3.3V G/Y(M) +3.3V B(M) R,G,B B/PB(M) MAIN VIDEO R(S) 24bit 8-bit Block R/PR(S) CLAMP Loop G(S) G/Y(S) PHD8UK ONLY B(S) HSYNC HSYNC 1.2V...
Page 296 DIGITAL SIGNAL PROCESSOR FORMAT CONVERTER, PlASMA AI TO C24 SUB-FIELD PROCESSOR DOUTU19A U19A-U21C IC9302 IC9501 DOUTU21C 1.5V 2.5V 3.3V 1.5V 2.5V 3.3V DRVRST SIGNAL PROCESSOR PLASMA AI 3.3V P+5V FORMAT CONVERTER SUB-FIELD PROCESSOR VIDEO DATA 1.5V 2.5V 3.3V 1.5V 2.5V 3.3V P+5V Q9301...
Page 297 HB BNC COMPOSITE VIDEO / S_VIDEO IC3104 IC3201 RESET MEMORY FIFO IC3103 IC3251 GC2M LVDS TRANSMITTER IC3003 J-BOARD SLOT MEMORY CONTROLLOR TX0+ TX0+ TX0- Q3006 Q3101,3102 TX0- TX1+ BUFFER BUFFER TX1+ Q3002 Color TX1- JK3001 IC3001 2DScalar Output TX1- Analog Adaptive Decoder Comb...
Page 298 SLOT INTERFACE/SYNC PROCESSOR/SOUND PROCESSOR S_CLOCK3 S_DATA3 RESET TO P5 AUDIO MUTE DIG+12V DIG+12V AUDIO L DR15V AUDIO R AUDIO+12V AUDIO+12V AUDIO+12V Q2370 Q2371 12V DET 12V DET Q2372 MUTE SW D2303 Q2334 Q2333 12V DET 12V DET IC8100 AVR 12V IC801 AVR 9V AMP_STB_SW...
Page 299 TO HX1 STB5V J SLOT INTERFACE/SYNC PROCESSOR/SOUND PROCESSOR STB3.3V S_CLOCK3 IC3008 AA_SCL3 S_DATA3 IC3004 AA_SDA3 IIC ON/OFF STB5V IC3007 EX I/O(VIDEO/AUDIO SELECT) IC3003 STB5V EX.I/O(SLOT DET IIC CONTROL) (MAIN) AB_SCL3 AB_SCL3 STB5V IIC ON/OFF AB_SDA3 AB_SDA3 IC8014 AH_SLOT1_DET AC_SW0 AC_SCL3 AA_SCL3 RESET 3.3V...
Page 300 S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. S.R. 78V_L 78V_R Vda_75V DATA DRIVER DATA DRIVER DATA DRIVER PB31 PB32 FANx7 CONTROL PB33 PB34 PB30 PB35 SCAN OUT PB37 PB38 DIGITAL SIGNAL PROCESSOR SC23 (1.2V)3.3V 1.5V SS35 STB3.3V DC/DC VSUS 15VD...
Page 301 CN04 CNPFC RF1601 3A L1604 POWER SUPPLY MC1604 MC1601 AC IN (1/2) RECTIFIER CN02 D709 T701 K1601 K1602 (2/2) L1601 L1602 LIVE F701 DC(+) VS_OUT F1601 Q703 VS_OHP NEUTRAL DC(-) F1602 IC701 Z1602 ZD702 PFC_ON CN03 VS_STOP (2/2) ZD703 HV_ON VR701 LIVE Q1606...
Page 302 POWER SUPPLY (2/2) COLD MC601 PFC(POWER FACTOR CONTROL) RF601 3A L604 MC604 CN05 Vsus RECTIFIER VSUS (1/2) K601 K602 L601 L602 LIVE DC(+) F601 F603 VR351 Z601 Z602 VSUS SS11 NEUTRAL DC(-) VSUS F602 S1 G1 S2 G2 Z603 MC301 COLD Q605 Q606...
Page 303 TPVSET COLD FLOATING GND SC SCAN DRIVE SU SCAN OUT (UPPER) TPSC1 WAVEFORM TPVSUS TO P2 VSET VSET Gen. PDP SCAN Vsus IC6654 IC6653 IC6652 TPVSET (+230V) DRIVERx6 +5V(SC1) VSUS IC6812 +5V(SC2) +15V(SC1) VDDH +5V(SC1) D6902 IC6900 +20V LINE D6518 Q6577,Q6814 +15V Q6815...
Page 304 TO C44 SS51 VE Gen. SUSTAIN DRIVE TPVE (+150V) TPVe VR6250 Adj. D6257 SS52 IC6060 Q6256,Q6257 BUFFER TPSOS2 IC6252 SS23 TPVSUS TO P1 Vsus Q6118-Q6121 Q6160-Q6163 Vsus Gen. Q6100-Q6105 SS25 Q6140-Q6145 IC6100 OUTPUT FET DRIVER TO C35 Vda75V ENERGY RECOVERY Q6000-Q6002 Vda75V L6010-13...
Page 305 Parts Location C1-BOARD IC7102 IC7104 IC7105 IC7106 IC7107 C1-BOARD (FOIL SIDE) TNPA3663 TNPA3663 1 2 3 CRNO.7 SEE REVERSE FOR ORDER NO. C1-BOARD (COMPONENT SIDE) TNPA3663 L107 L108 L105 L106 L102 L101 L104 L103 C163 R118 R116 C156 R132 C198 R154 R120 C121...
Page 306 Parts Location C2-BOARD IC7201 IC7202 IC7203 IC7204 IC7205 IC7206 IC7207 IC7208 IC7209 IC7210 IC7211 IC7212 C2-BOARD (FOIL SIDE) TNPA3664 TNPA3664 REVERSE FOR ORDER C2-BOARD (COMPONENT SIDE) TNPA3664 L203 L204 R264 R263 L208 L207 R229 C237 R249 R244 C224 C203 C212 C252 R227 C261...
Page 307 Parts Location C3-BOARD IC7301 IC7302 IC7303 IC7304 IC7305 C3-BOARD (FOIL SIDE) TNPA3665 1 2 3 TNPA3665 CRNO.7 REVERSE FOR ORDER C3-BOARD (COMPONENT SIDE) TNPA3665 CA10 L302 L301 CA11 R365 ZA301 L306 L305 L308 L307 ZA302 C339 C389 C363 R361 C390 R363 C393 C397...
Page 308 Parts Location C4-BOARD IC7401 IC7402 IC7403 IC7404 IC7405 C4-BOARD (FOIL SIDE) TNPA3666 CRNO.7 TNPA3666 REVERSE FOR ORDER 1 2 3 C4-BOARD (COMPONENT SIDE) TNPA3666 C408 C412 R413 ZA403 ZA404 C409 C404 R447 C413 CRNO.7 R405 C410 R402 C406 R406 R407 R408 C414 R417...
Page 309 Parts Location C5-BOARD IC7501 IC7502 IC7503 IC7504 IC7505 IC7506 IC7507 IC7508 IC7509 IC7510 IC7511 IC7512 IC7513 C5-BOARD (FOIL SIDE) TNPA3667 TNPA3667 REVERSE FOR ORDER CRNO.7 C5-BOARD (COMPONENT SIDE) TNPA3667 IC508 R510 C562 R618 R525 C568 R616 R514 FL502 C563 C567 R620 TNPA3667 ZA502...
Page 310 Parts Location C6-BOARD IC7602 IC7603 IC7604 IC7605 IC7606 C6-BOARD (FOIL SIDE) TNPA3668 TNPA3668 REVERSE FOR ORDER 1 2 3 CRNO.7 C6-BOARD (COMPONENT SIDE) TNPA3668 R651 CRNO.7 R642 IC604 R638 R606 IC602 R670 R655 R648 R647 R672 R669 C6MM3 R620 C6MM1 TNPA3668 IC603 R619...
Page 311 D-BOARD (COMPONENT SIDE) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) R981 C377 C375 C992 D705 R593 X701 R567 R396 R473 R418 R424 R569 C636 R427 R429 R568 R435 R437 R439 C991 R595 C081 C780 R766 R835 C708 R777 TP302 R768 C515 C614 R629...
Page 312 D-BOARD (FOIL SIDE) TZTNP01YUSE (TH-65PHD8BK/EK) TZTNP020YUS (TH-65PHD8UK) R891 FL706 R984 FL300 R892 FL703 R476 C994 C716 C993 FL301 C443 FL704 R985 R812 R815 R818 R814 R817 IC605 IC953 R811 R492 R491 Q074 R109 C103 D702 C715 D706 C720 D704 R128...
Page 313 HA-BOARD(FOIL SIDE) HA-BOARD(COMPONENT SIDE) TXNHA10RBS TXNHA10RBS (UK) TNPA2845 ORDER TP034 TP036 CR NO.3 JS009 JS007 C022 Parts Location JS008 R038 JS010 R040 R041 R042 HA-BOARD IC3001 TP3032 IC002 IC3002 TP3033 C017 TP3034 JS001 C018 TRANSISTOR C016 R037 TP3035 C021 R036 TP3036 JS004 Q3001...
Page 314 HB-BOARD (FOIL SIDE) HB-BOARD(COMPONENT SIDE) TXNHB10QXS TXNHB10QXS (BK, EK) (UK) 2 HV TNPA2844 A1 A2 A1 A2 ORDER Parts Location HB-BOARD C324 C324 C329 C329 C330 C330 C321 C321 TRANSISTOR L308 L308 L307 L307 IC251 IC251 C319 C319 IC3001 Q3001 R300 C266 C266...
Page 315 HX-BOARD(FOIL SIDE) HX-BOARD(COMPONENT SIDE) TZTNP040VAS TZTNP040VAS TNPA3400 TNPA3400 REVERSE FOR ORDER ORDER CR NO.3 CR NO.3 C409 C405 C404 IC502 R400 L555 R589 C523 R778 C563 D502 C524 R788 D504 R789 R794 D506 R586 Q537 C551 R593 R592 R591 R528 R527 R526 C550...
Page 316 IC3008 Q2334 Q8018 TPJV2 IC3101 Q2370 Q8019 IC3102 Q2371 Q8020 IC3150 Q2372 Q8021 IC8001 Q3001 Q8023 IC8002 J-BOARD (COMPONENT SIDE) TNPA3630AD (TH-65PHD8BK/EK) TNPA3630AC (TH-65PHD8UK) TNPA3630 D3005 R2374 R2365 R3144 L2330 R3143 ORDER R3024 D3008 C2358 C2352 R2420 C2410 R2421 R2422...
Page 317 Parts Location J-BOARD (FOIL SIDE) TRANSISTOR IC2301 Q3002 IC2302 Q3003 IC8003 IC8004 J-BOARD (FOIL SIDE) TNPA3630AD (TH-65PHD8BK/EK) TNPA3630AC (TH-65PHD8UK) R2365 TNPA3630 R2408 R2409 R2374 REVERSE FOR ORDER L2330 D3061 C3203 C3202 C3201 IC2301 L2331 R3111 R813 R3204 R2399 IC2302 R3142...
Page 318 P(P-1)-BOARD (COMPONENT SIDE) ETXMM584MEK (NPX584ME-1) Parts Location P-BOARD (COMPONENT SIDE) MC301 MC302 MC303 MC601 MC602 MC604 MC605 TH-65PHD8 SERIES TH-65PHD8 SERIES P-BOARD ETXMM584MEK P-BOARD ETXMM584MEK...
Page 319 P(P-1)-BOARD (FOIL SIDE) ETXMM584MEK (NPX584ME-1) Parts Location P-BOARD (FOIL SIDE) TRANSISTOR MC301 Q332 MC302 Q333 MC303 Q602 MC601 Q603 MC602 Q605 MC604 Q606 MC605 TH-65PHD8 SERIES TH-65PHD8 SERIES P-BOARD ETXMM584MEK P-BOARD ETXMM584MEK...
Page 320 P(P-2)-BOARD (COMPONENT SIDE) ETXMM584MEK (NPX584ME-2) Parts Location P-BOARD (COMPONENT SIDE) TRANSISTOR IC401 Q1601 IC701 IC901 MC401 MC701 MC801 MC901 MC902 MC1601 MC1602 MC1604 TH-65PHD8 SERIES TH-65PHD8 SERIES P-BOARD ETXMM584MEK P-BOARD ETXMM584MEK...
Page 321 P(P-2)-BOARD (FOIL SIDE) ETXMM584MEK (NPX584ME-2) Parts Location P-BOARD (FOIL SIDE) TRANSISTOR IC401 Q402 IC701 Q451 IC901 Q452 MC401 Q453 MC701 Q454 MC801 Q703 MC901 Q951 MC902 Q952 MC1601 Q953 MC1602 Q954 MC1604 Q955 Q956 Q1601 Q1602 Q1603 Q1605 Q1606 TH-65PHD8 SERIES TH-65PHD8 SERIES P-BOARD ETXMM584MEK P-BOARD ETXMM584MEK...
Page 322 Parts Location PB-BOARD (FOIL SIDE) TRANSISTOR IC850 Q850 TPFAN Parts Location PB-BOARD (COMPONENT SIDE) TRANSISTOR IC850 Q850 PB-BOARD (FOIL SIDE) PB-BOARD (COMPONENT SIDE) TNPA3655AB TNPA3655AB TNPA3655 R861 Q850 R861 ORDER R852 R852 D857 R859 R853 C850 R853 C850 J101 D855 D855 R858 R862...
Page 323 SC-BOARD (COMPONENT SIDE) TNPA3669 R756 D639 D640 C638 R755 Q604 R601 R602 R606 C635 R757 IC640 R477 R475 D641 D505 R758 ZA402 ZA401 L680 R615 SC44 R759 SC43 SC42 SC41 R845 Q601 R760 TPSC1 Q630 Q631 Q632 Q633 Q634 Q635 Q636 Q642 Q637...
Page 324 SC-BOARD (FOIL SIDE) TNPA3669 L680 C636 SC41 SC42 SC43 SC44 R845 C623 Q814 R827 C806 Q815 VR602 C614 C658 L813 C615 R812 R811 Q602 Q813 VR802 L811 R860 L812 D528 D525 D529 D527 D526 TP058 TP054 TP060 Q506 Q505 Q504 Q503 Q502 Q501...
Page 325 Parts Location Parts Location SC-BOARD (FOIL SIDE) SC-BOARD (COMPONENT SIDE) TRANSISTOR TP6037 Q6576 Q6655 TP6038 Q6577 Q6656 IC6411 Q6411 IC6801 TP6005 TP6039 Q6601 Q6657 IC6412 Q6412 TP6006 TRANSISTOR TP6040 Q6602 Q6658 IC6413 Q6413 TP6007 TP6041 Q6604 Q6659 IC6421 Q6501 TP6008 Q6501 TP6042 Q6611...
Page 326 Parts Location SD-BOARD IC6920 TPSD21 IC6921 TPSD22 IC6922 TPSD23 IC6923 TPSD24 IC6924 TPSD25 IC6925 TPSD26 SD-BOARD (FOIL SIDE) TNPA3674 TNPA3674 1 SD REVERSE FOR ORDER 1 2 3 SDMM1 SD-BOARD (COMPONENT SIDE) TNPA3674 TPSD26 TPSD22 TPSD24 TPSD21 TPSD23 TPSD25 TNPA3674 ORDER C6937 C6928...
Page 327 SS2-BOARD (FOIL SIDE) TNPA3671 SS51 SS52 SS23 TNPA3671 REVERSE FOR ORDER SS2-BOARD (COMPONENT SIDE) TNPA3671 SS23 SS52 SS51 TNPA3671 ORDER SS3-BOARD (FOIL SIDE) TNPA3672 TNPA3672 REVERSE FOR ORDER SS58 SS57 1 2 3 SS27 SS3-BOARD (COMPONENT SIDE) TNPA3672 TNPA3672 ORDER SS57 SS58 SS27...
Page 328 SS-BOARD (COMPONENT SIDE) TNPA3670 Q007 R098 D241 R095 R246 R092 L205 L206 L207 L201 L200 L202 C220 R220 L230 R056 R233 R234 R217 R055 JS200 JS201 R091 R089 SSMM1 R094 Q005 Q006 Q240 L180 R093 R097 R245 R213 C060 R238 R214 Q212 TP15V...
Page 329 SS-BOARD (FOIL SIDE) TNPA3670 TP19 SS12 TP23 Q240 TP10 L180 L200 L201 TP913 L202 L207 L206 L205 TP21 TP17 TP918 SS11 L239 TP16 TP18 TP11 TP20 C224 C063 TP12 TP14 C061 TP33 TP32 TP13 C240 L204 L203 TP923 C234 TP921 TP919 C214 C215...
Page 330 Parts Location Parts Location SS-BOARD (FOIL SIDE) SS-BOARD (COMPONENT SIDE) TRANSISTOR TRANSISTOR TP24 Q6142 Q6252 TP25 Q6143 Q6253 IC6000 Q6000 Q6000 TP26 Q6144 Q6254 IC6020 Q6001 Q6001 TP27 Q6145 Q6255 IC6060 Q6002 Q6002 TP28 Q6160 Q6256 IC6061 Q6003 Q6003 TP29 Q6161 Q6257 IC6062...

This manual is also suitable for:

Th-65phd8ek Th-65phd8uk

Panasonic TH-65PHD8BK Service Manual

Quick Links

Related Manuals for Panasonic TH-65PHD8BK

Summary of Contents for Panasonic TH-65PHD8BK

This manual is also suitable for:

Table of Contents