hit counter script
Download
Share
Print this page
Sanyo EM-V5405SW Supplement Of Service Manual
  1. Manuals
  2. Brands
  3. Sanyo Manuals
  4. Microwave Oven
  5. EM-V5405SW
  6. Supplement of service manual
Sanyo EM-V5405SW Supplement Of Service Manual

Sanyo EM-V5405SW Supplement Of Service Manual

Hide thumbs Also See for EM-V5405SW:

Advertisement

Quick Links

Download this manual
SUPPLEMENT OF
SUPPLEMENT OF
SUPPLEMENT OF
SUPPLEMENT OF
SUPPLEMENT OF
SERVICE MANUAL
SER
SER
VICE MANUAL
VICE MANUAL
VICE MANUAL
SER
SER
VICE MANUAL
PRECAUTIONS TO BE OBSERVED BEFORE AND DURING
SERVICING TO AVOID POSSIBLE EXPOSURE TO
(a) Do not operate or allow the oven to be operated with the door open.
(b) Make the following safety checks on all ovens to be serviced before activating the magnetron or other
microwave source, and make repairs as necessary :
(1) Interlock operation, (2) proper door closing, (3) seal and sealing surfaces (arcing, wear, and other damage),
(4) damage to or loosening of hinges and latches, (5) evidence of dropping or abuse.
(c) Before turning on microwave power for any service test or inspection within the microwave generating
compartments, check the magnetron, wave guide or transmission line, and cavity for proper alignment, integrity,
and connections.
(d) Any defective or misadjusted components in the interlock, monitor, door seal, and microwave generation and
transmission systems shall be repaired, replaced, or adjusted by procedures described in this manual before
the oven is released to the owner.
(e) A microwave leakage check to verify compliance with the Federal performance standard should be performed
on each oven prior to release to the owner.
Micr
Microwave Oven
Micr
owave Oven
owave Oven
owave Oven
Micr
Micr
owave Oven
W W W W W ARNING TO SER
ARNING TO SER
ARNING TO SER
ARNING TO SER
ARNING TO SERVICE TECHNICIANS
EXCESSIVE MICROWAVE ENERGY
Pr Pr Pr Pr Product Code No.
oduct Code No.
oduct Code No.
oduct Code No.
oduct Code No.
See the Service Manual of EM-F3400SW (SM-860304)
except the items described in this Service Manual.
CAUTION
CAUTION
CAUTION
CAUTION
CAUTION
VICE TECHNICIANS
VICE TECHNICIANS
VICE TECHNICIANS
VICE TECHNICIANS
File No :
File No :
File No :
File No :
File No :
EM-V5405SW (U.S.A.)
EM-V5405SW (U.S.A.)
EM-V5405SW (U.S.A.)
EM-V5405SW (U.S.A.)
EM-V5405SW (U.S.A.)
437 540 00
437 540 00
437 540 00
437 540 00
437 540 00
REFERENCE NO. SS-860313

Advertisement

loading

Related Manuals for Sanyo EM-V5405SW

Summary of Contents for Sanyo EM-V5405SW

  • Page 1 SUPPLEMENT OF SUPPLEMENT OF SUPPLEMENT OF SUPPLEMENT OF SUPPLEMENT OF Micr Micr Microwave Oven owave Oven owave Oven owave Oven EM-V5405SW (U.S.A.) EM-V5405SW (U.S.A.) EM-V5405SW (U.S.A.) Micr Micr owave Oven EM-V5405SW (U.S.A.) EM-V5405SW (U.S.A.) SERVICE MANUAL VICE MANUAL VICE MANUAL...
  • Page 2 In the area emitting the highest reading, switch the meter CAUTION CAUTION CAUTION CAUTION CAUTION to SLOW RESPONSE, and take a reading for minimum of three (3) seconds. We recommended the pattern outline For micr For micr For micr For micr For microwave ener owave ener owave ener...

  • Page 3: Power Output Measurement

    - TABLE OF CONTENTS - Specifications ..............Test Procedures ............Power Output Measurement ........... Exploded View and Parts List ........ 4 ~ 9 Circuit Diagram ............... Overall Circuit Diagram .......... 1. SPECIFICA 1. SPECIFICA 1. SPECIFICA 1. SPECIFICA 1. SPECIFICATIONS TIONS TIONS TIONS...

  • Page 4: Circuit Diagram

    3. CIRCUIT DIAGRAM 3. CIRCUIT DIAGRAM 3. CIRCUIT DIAGRAM 3. CIRCUIT DIAGRAM 3. CIRCUIT DIAGRAM Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 WIRING COLOR O : ORANGE B K : BLACK R : RED B L : BLUE W : WHITE Y : YELLOW - 2 -...

  • Page 5: Test Procedures

    4. TEST PROCEDURES 4. TEST PROCEDURES 4. TEST PROCEDURES 4. TEST PROCEDURES 4. TEST PROCEDURES COMPONENT COMPONENT COMPONENT CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE RESUL RESULT T T T T RESUL COMPONENT COMPONENT CHECKOUT PROCEDURE CHECKOUT PROCEDURE RESUL RESUL When When not Measure the resistance between terminals of touched...
  • Page 6 5 . 5 . 5 . 5 . 5 . EXPLODED VIEW AND P EXPLODED VIEW AND P EXPLODED VIEW AND P TS LIST TS LIST EXPLODED VIEW AND P EXPLODED VIEW AND PAR ARTS LIST TS LIST TS LIST CAVITY PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING...
  • Page 7 SWITCHES AND MICROWAVE PARTS ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 411 082 5201 SCR TPG TRS 4 x 10 Z1...
  • Page 8 DOOR PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No Description Q’ty 617 235 4125...
  • Page 9 CONTROL PANEL PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 617 235 1636...

  • Page 10: Control Circuit Board

    CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 230 8371 617 230 8371 617 230 8371 617 230 8371) 617 230 8371 - 8 -...
  • Page 11 CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 230 8371 617 230 8371 617 230 8371 617 230 8371 617 230 8371) Key No. Order Part No. Description Q’ty Key No. Order Part No.
  • Page 12 For Parts or Service Contact For Parts or Service Contact SANYO FISHER SER SANYO FISHER SER SANYO FISHER SER SANYO FISHER SER SANYO FISHER SERVICE COMP VICE COMP VICE COMP VICE COMP VICE COMPANY 21605 Plummer Street, Chatsworth, CA91311 U.S.A.
  • Page 13 File No : File No : File No : File No : File No : SERVICE MANUAL VICE MANUAL VICE MANUAL VICE MANUAL VICE MANUAL Micr Micr owave Oven owave Oven EM-F3400SW EM-F3400SW Micr Microwave Oven Micr owave Oven owave Oven EM-F3400SW EM-F3400SW EM-F3400SW...
  • Page 14 In the area emitting the highest reading, switch the meter CAUTION CAUTION CAUTION CAUTION CAUTION to SLOW RESPONSE, and take a reading for minimum of three (3) seconds. We recommended the pattern outline For micr For micr For micr For micr For microwave ener owave ener owave ener...
  • Page 15 VICE PERSONNEL. PERSONNEL. PERSONNEL. Door Latch The SANYO service center should have the designated detector to measure the microwave energy leakage Lever Stopper after the repair or adjustment. NOTE NOTE NOTE : Detector to be used at the service center is...
  • Page 16 4 . 4 . 4 . 4 . 4 . PRECAUTIONS AND REP PRECAUTIONS AND REP PRECAUTIONS AND REP AIR SER AIR SER VICE TIPS VICE TIPS 2 . 2 . 2 . 2 . 2 . SPECIFICA SPECIFICA SPECIFICA TIONS TIONS PRECAUTIONS AND REP...
  • Page 17 5. CIRCUIT DIAGRAM Figure 2 Figure 2 Figure 2 Figure 2 Figure 2 • • • • • - 3 -...

  • Page 18: Test Procedures And Troubleshooting

    6. TEST PROCEDURES AND TROUBLESHOOTING 6. TEST PROCEDURES AND TROUBLESHOOTING Filament Windings 6. TEST PROCEDURES AND TROUBLESHOOTING 6. TEST PROCEDURES AND TROUBLESHOOTING 6. TEST PROCEDURES AND TROUBLESHOOTING CAUTION CAUTION CAUTION CAUTION CAUTION - DISCONNECT THE POWER SUPPL - DISCONNECT THE POWER SUPPL Y CORD FROM Y CORD FROM - DISCONNECT THE POWER SUPPL...
  • Page 19 COMPONENT COMPONENT COMPONENT COMPONENT COMPONENT CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE RESUL RESUL RESUL RESUL RESULT T T T T Measure the resistance : Across two terminals Normal reading : with an Ohm-Meter on highest scale. Momentarily indicates several Ohms, HIGH-VOLTAGE and gradually returns to 10 Meg-Ohms.
  • Page 20 COMPONENT COMPONENT COMPONENT COMPONENT COMPONENT CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE RESUL RESUL RESUL RESUL RESULT T T T T When When not Measure the resistance between terminals of touched touched Resistance FPC connector after removing it from S101. value Less than More than...
  • Page 21 - 7 -...
  • Page 22 - 8 -...
  • Page 23 - 9 -...
  • Page 24 - 10 -...
  • Page 25 7 . 7 . 7 . 7 . 7 . DISASSEMBL DISASSEMBL DISASSEMBL DISASSEMBLY INSTRUCTIONS Y INSTRUCTIONS Y INSTRUCTIONS Y INSTRUCTIONS DISASSEMBL Y INSTRUCTIONS • • • • • OVEN MUST BE DISCONNECTED FROM ELECTRICAL OVEN MUST BE DISCONNECTED FROM ELECTRICAL OVEN MUST BE DISCONNECTED FROM ELECTRICAL B.
  • Page 26 C. C. C. C. C. REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR (Figures 11 (Top View) and 12). Duct (mag. exhaust) Blower Base (1) Remove screw securing the stay. (2) Disconnect all lead wires from the blower motor and H.V.
  • Page 27 E. E. E. E. E. REMOVING FUSE REMOVING FUSE REMOVING FUSE REMOVING FUSE REMOVING FUSE Remove the 20A fuse with a screwdriver. NOTE NOTE NOTE NOTE NOTE When replacing the 20A fuse, be sure to use an exact repair part. Control Base If the 20A fuse blows immediately, check the primary interlock switch, the relay 2 (on the control circuit board)

  • Page 28: Removing Door

    H. H. H. H. REMOVING DOOR REMOVING DOOR REMOVING DOOR REMOVING DOOR REMOVING DOOR J. J. J. J. J. REMOVING CA REMOVING CA REMOVING CA VITY COVER VITY COVER REMOVING CA REMOVING CAVITY COVER VITY COVER VITY COVER (Figure 16) (1) Remove 2 hex nuts securing the upper hinge.
  • Page 29 8 . 8 . 8 . 8 . 8 . EXPLODED VIEW AND P EXPLODED VIEW AND P EXPLODED VIEW AND P TS LIST TS LIST EXPLODED VIEW AND P EXPLODED VIEW AND PAR ARTS LIST TS LIST TS LIST CAVITY PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING...
  • Page 30 SWITCHES AND MICROWAVE PARTS ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 411 082 5201 SCR TPG TRS 4 x 10 Z1...
  • Page 31 DOOR PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No Description Q’ty 617 229 2403...
  • Page 32 CONTROL PANEL PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 617 230 7787...

  • Page 33: Control Circuit Board

    CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 230 2324 617 230 2324 617 230 2324 617 230 2324 617 230 2324) - 19 -...
  • Page 34 CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 230 2324 617 230 2324 617 230 2324 617 230 2324) 617 230 2324 Key No. Order Part No. Description Q’ty Key No. Order Part No.
  • Page 35 9 . 9 . 9 . 9 . 9 . OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM - 21 -...
  • Page 36 This file has been downloaded from: www.UsersManualGuide.com User Manual and User Guide for many equipments like mobile phones, photo cameras, monther board, monitors, software, tv, dvd, and othes.. Manual users, user manuals, user guide manual, owners manual, instruction manual, manual owner, manual owner's, manual guide, manual operation, operating manual, user's manual, operating instructions, manual operators, manual operator, manual product, documentation manual, user maintenance, brochure, user reference, pdf manual...

This manual is also suitable for:

Em-f3400sw437 540 00437 450 57