Table of Contents
Advertisement
Refer to "HANDLEBAR" on page 4-60.
2. Check:
• Throttle grip movement
Rough movement Lubricate or replace the
defective part(s).
Recommended lubricant
Suitable cable lubricant
TIP
With the engine stopped, turn the throttle grip
slowly and release it. Make sure that the throttle
grip turns smoothly and returns properly when
released.
Repeat this check with the handlebar turned all
the way to the left and right.
3. Check:
• Throttle grip free play "a"
Out of specification Adjust.
Throttle grip free play
3.0–5.0 mm (0.12–0.20 in)
a
4. Adjust:
• Throttle grip free play
TIP
Prior to adjusting the throttle grip free play, throt-
tle body synchronization should be adjusted
properly.
▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼
a. Slide back the rubber cover "1".
b. Loosen the locknut "2".
c. Turn the adjusting nut "3" in direction "a" or "b"
until the specified throttle grip free play is ob-
tained.
Direction "a"
Throttle grip free play is increased.
Direction "b"
Throttle grip free play is decreased.
PERIODIC MAINTENANCE
d. Tighten the locknut.
e. Slide the rubber cover to its original position.
TIP
Make sure that the adjusting nut is covered com-
pletely by the rubber cover.
▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲
EAS30816
CHECKING AND CHARGING THE BATTERY
Refer to "CHECKING AND CHARGING THE
BATTERY" on page 8-152.
EAS30662
CHECKING THE FUSES
Refer to "CHECKING THE FUSES" on page
8-151.
EAS30665
REPLACING THE HEADLIGHT BULB
1. Remove:
• Headlight lens unit bolt "1"
• Headlight lens unit "2"
2
1
2. Disconnect:
• Headlight coupler "3"
3. Remove:
• Headlight bulb cover "4"
3-29
1
2 3
a
b
Advertisement
Chapters
Table of Contents
Troubleshooting
