hit counter script
Philips AZ1009 Service Manual
  1. Manuals
  2. Brands
  3. Philips Manuals
  4. Recording Equipment
  5. AZ 1009
  6. Service manual

Philips AZ1009 Service Manual

Cd stereo radio recorder
Hide thumbs Also See for AZ1009:
Table of Contents

Advertisement

Quick Links

See also: Instructions for Use Manual
CD Stereo Radio Recorder
Service Manual

TABLE OF CONTENTS

Technical Specification ................................................2-1
Measurement setup .....................................................2-2
Controls & Connections ...............................................2-3
Brief Operating Instructions ....................................2-4 to 2-7
Warnings & Safety .......................................................2-8
Dismantling Instructions..........................................3-1 to 3-3
Service hints ...........................................................3-4 to 3-6
CD - startup procedure ................................................3-7
Abbreviations CD-ICs ..................................................3-8
Service Test Program .................................................3-10
BLOCK DIAGRAM .......................................................4-1
WIRING DIAGRAM......................................................5-1
schematic diagram ..................................................6-1
component layout ....................................................6-2
adjustment table ......................................................6-2
©
Copyright 1997 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
Published by MS 9741 Service Audio
CS 49 101
xystus
chapter
Printed in The Netherlands
Subject to modification
AZ1009
AZ1010
component layout .................................................7-1
schematic diagram .................................................7-2
component layout ................................................7-1, 7-4
schematic diagram CD part.....................................7-2
Recorder/Amplifier part ............7-3
apparatus, drawing 1 ...............................................8-1
apparatus, drawing 2 ...............................................8-2
tape transport ..........................................................8-3
MECHANICAL PARTSLIST see Exploded views
ELECTRICAL PARTSLIST.........................................9-1 ff
/00/05/17
/00/01/04/05/10
/11/11H/14/17
chapter
CLASS 1
LASER PRODUCT
© 4822 725 26015

Advertisement

Table of Contents
loading

Related Manuals for Philips AZ1009

Summary of Contents for Philips AZ1009

  • Page 1: Table Of Contents

    LASER PRODUCT © Copyright 1997 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.

  • Page 2: Technical Specification

    TECHNICAL SPECIFICATION General: Mains voltage : 220V-230V / 50Hz for /00 /04 /14 230V-240V / 50Hz for /05 /10 110V-127V / 220V-240V /50Hz switchable for /01 /11 /11H 120V / 60Hz for /17 Battery : 9V ( 6xR20 ) : ≤ 15W at maximum output power, ( ≤ 11W at 1/8 P Power consumption ≤...

  • Page 3: Measurement Setup

    MEASUREMENT SETUP Tuner FM Bandpass LF Voltmeter 250Hz-15kHz e.g. PM2534 e.g. 7122 707 48001 RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Tuner AM (MW,LW) Bandpass LF Voltmeter...
  • Page 4 CONNECTIONS & CONTROLS BASIC FUNCTIONS RADIO 1 POWER: 6 TUNING ....tunes to radio stations CD, TAPE, BAND..selects the sound source 1 BAND: FM, MW ...selects the wave band 2 DBB.......enhances the bass 3 VOLUME ....adjusts the volume level 7 CD PLAYER 4 p......3.5mm headphone socket (back of the set) / OPEN ....opens the CD compartment Note: Connecting the headphones will switch off the speakers.
  • Page 5 INSTRUCTION FOR USE English CS 49 105...
  • Page 6 INSTRUCTION FOR USE English CS 49 106...
  • Page 7 INSTRUCTION FOR USE English CS 49 107...
  • Page 8 INSTRUCTION FOR USE CS 49 108...

  • Page 9: Warnings & Safety

    WARNINGS & SAFETY © ñ WARNING WAARSCHUWING All ICs and many other semiconductors are susceptible to Alle IC´s en vele andere halfgeleiders zijn gevoelig voor electrostatic discharges (ESD). Careless handling during electrostatische ontladingen (ESD). repair can reduce life drastically. Onzorgvuldig behandelen tijdens reparatie kan de levensduur When repairing, make sure that you are connected with the drastisch doen vermindern.

  • Page 10: Dismantling Instructions

    DISMANTLING INSTRUCTIONS Dismantling of the Cassette Door • Open cassette door. • Release left catch by pressing it inwards with a screwdriver as shown in picture 1. • Pull door on left side up as shown in picture 2. • Right catch will now be released automatically. picture 1 picture 2 Dismantling of the CD Door...
  • Page 11 DISMANTLING INSTRUCTIONS Dismantling the Top Cabinet • Loosen 6 screws as shown in picture 5. • Remove handle by pulling it backwards. picture 5 • Pull volume knob off. • Pull Top cabinet on rear side up first. • Move it backwards to release lugs on front side.
  • Page 12 DISMANTLING INSTRUCTIONS Dismantling of the Tape Transport • Dismantle top cabinet as described page before. • Remove cassette door as described in chapter 3-1. • Loosen 4 screws as shown in picture 8. • Put ornamental cover away. • Fetch tape transport through cassette compartment out as shown in picture 9.

  • Page 13: Service Hints

    SERVICE HINTS SERVICE TOOLS TORX T10 screwdriver with shaftlength 150mm ........4822 395 50423 TORX screwdriver set SBC 163 ..............4822 295 50145 Audio signal disc SBC 429..............4822 397 30184 Playability test disc SBC444 ..............4822 397 30245 Test disc 5 (disc without errors) + Test disc 5A (disc with dropout errors, black spots and fingerprints) SBC 426/426A ..............4822 397 30096 Burn in test disc (65 min.
  • Page 14 SERVICE HINTS General Service position For repairs on: CD failures Rec/Pb-amplifier Power-amplifier Power supply Tuner Board picture 12 Service position Tape Transport For repairs on the Tape Transport or for adjustment of the tape speed: • Dismantle tape transport as described in chapter 3-3.
  • Page 15 SERVICE HINTS Alignment of AZIMUTH • Remove casstte door as described in chapter 3-1. • Insert testcassette SBC420 (4822 397 30071) directly into cassette compartment and play 10kHz part. • Adjust right hand screw for max. output and left channel = right channel. picture 14 Details wire routing of mains transformer Wire routing has to be carried out as shown in picture...

  • Page 16: Cd Startup Procedure

    CD STARTUP PROCEDURE CD switched on Remark: To check focus servo, slide servo, track servo and turntable BEGIN (mode switch) use service test program +A(CD) - Battery empty? supplied to - check +A, CD part? - mode switch o.k.? check: - +A(CD), +B(CD), +LASER, +M, Decoder delivers CLOCK - - time constant of reset circuit frequ.
  • Page 17 Pin-descriptions of CD ICs SERVO PROCESSOR M62475FP Name Direction Description Diode array → Servo processor A, B, C Current input ( central photo diode signal input ) Diode array → Servo processor E, F Current input ( satellite photo diode signal input ) Servo processor →...
  • Page 18 NOTES CS 49 118...

  • Page 19: Service Testprogram

    3-10 3-10 SERVICE TESTPROGRAM SERVICE TESTPROGRAM To enter Service To leave Service Testprogram switch Testprogramm hold CD mode off. PLAY & STOP buttons Door switch is ignored → CD door can be opened. depressed while switching CD mode on. Display shows Slide servo, Radial servo, Focus servo, Disc motor version number of the µ...

  • Page 20: Block Diagram

    BLOCK DIAGRAM 1820 FRONT BOARD REPEAT SHUFFLE TUNER BOARD Stab Stab AM/FM PROGRAM switch FM-IF 1 FM-IF 2 7102 FM-RF Discr. TELESCOPIC ANTENNA LF filter 10,7 MHz 10,7 MHz 1813 1101 COMBI BOARD left left Stereo right 1812 1201 Decoder frontend Mixer Det.

  • Page 21: Wiring Diagram

    WIRING DIAGRAM CD DRIVE CD94V5T1 (top view) DETAIL CD-DRIVE: connection of metal frame to ground TOP VIEW BOTTOM VIEW BATTERY COMPARTMENT 6 x 1.5V TELESCOPIC (R20) ANTENNA DOOR SWITCH +Batt. 1809 slide motor 8800 8011 loosen screw and fasten again with cable 1006 8012 8102...
  • Page 22 1101 B14 AM-IF1 468kHz AM-IF2 468kHz 2101 B 4 TUNER BOARD 5106 5108 2102 B 4 2103 F 5 REF_A 2104 F 6 2105 H 5 2118 2106 I 6 2106 I11 REF_A 2106 F 5 2106 H 5 2108 I 7 2109 I 6 FM-IF2 2110 I10...
  • Page 23 TUNER ADJUSTMENT TABLE 0001 B 2 2104 A 2 2111 B 3 2117 A 4 2123 A 2 3109 A 4 5104 B 2 5108 A 1 9101 B 2 1101 A 4 2105 A 2 2112 B 1 2118 A 4 3101 B 4 3110 A 4 5105 B 3...
  • Page 24 1201 B 1 2815 D 3 3315 B 7 3843 A 3 7800 C 1 7801 D 4 1202 C 6 2816 E 2 3316 B 6 3844 D 1 3551 A 2 3845 D 4 7802 D 4 1203 C 5 2817 E 2 2818 E 2 3552 A 2...
  • Page 25 1800 E 4 3894 B14 1820 1801 E 4 3895 C28 FRONT BOARD COMBI BOARD / 1802 F 4 3896 B28 CD-PART RESET CIRCUIT 3897 L25 1803 G 4 REPEAT SHUFFLE 1804 G 4 3898 M25 DECODER PART SIGNAL PROCESSOR 3817 Continuous Calibration DAC 1807 E15...

  • Page 26: Recorder/Amplifier Part

    1201 I 2 1202 K 5 1203 M 5 COMBI BOARD / 1204 N 5 3638 1250 1250 F10 2630 2638 1250 B10 RECORDER/AMPLIFIER PART SOURCE 1250 L10 SWITCH 1250 J10 REC/PB-AMP RIGHT from CD part 1301 G20 CD_R 1302 E19 3634 3636 1350 F12...
  • Page 27 3843 A 3 7800 C 1 1201 B 1 2815 D 3 3315 B 7 2816 E 2 3316 B 6 3844 D 1 7801 D 4 1202 C 6 7802 D 4 1203 C 5 2817 E 2 3551 A 2 3845 D 4 3552 A 2 3846 D 5...
  • Page 28 EXPLODED VIEW / DRAWING 1 MECHANICAL PARTS ––––––––––––––––––––––––––––––––––––––––––––––––––––– VOLUME 4822 410 11403 KEY-SET, TAPE TRANSPORT TAPE TRANSPORT, CDS-83VBF-77 4822 691 10612 4822 529 10322 DAMPER, DOOR Pl. Torx Pl. Torx 3x10 4822 492 42709 SPRING, OPEN CASSETTE DOOR 3x25 (2x) 4822 443 10832 CASSETTE DOOR ASSY, BLACK (2x)

  • Page 29: Exploded Views

    EXPLODED VIEW / DRAWING 2 Pl. Torx 3x10 (3x) DOOR SWITCH 1807 M2x6 Pl. Torx (2x) 2,6x10 (2x) MECHANICAL PARTS –––––––––––––––––––––––––––––––––––––––––––––––––––– 4822 529 10322 DAMPER, DOOR 4822 443 10833 CD DOOR, BLACK 4822 443 10819 CD DOOR, SILVER (2x) 4822 532 12798 CD CLAMP 4822 535 60096 DAMPING DISC CD...

  • Page 30: Tape Transport

    EXPLODED VIEW TAPE TRANSPORT Only those parts of which a service code number is stated are normal service parts. 4822 691 10612 TAPE TRANSPORT CDS-83VBF-77 110 4822 278 90721 LEAF SWITCH, MOTOR ON/OFF 10 4822 528 70849 PINCH ROLLER ARM 111 4822 249 30218 REC/PB-HEAD, MS18R-AKONI 11 4822 528 70695...

  • Page 31: Electrical Partslist

    ELECTRICAL PARTSLIST MECHANICAL PARTS CAPACITORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 0001 4822 256 90463 HOLDER FERRITE BAR 2627 4822 126 13507 91pF 2628 4822 126 13507 91pF MISCELLANEOUS 2629 4822 124 41579 10µF ––––––––––––––––––––––––––––––––––––––––––––––––––––– 2630 4822 124 41579 10µF 1250 4822 277 11739 SWITCH SLIDE, MODE 2631 4822 126 11714...
  • Page 32 ELECTRICAL PARTSLIST CAPACITORS RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3637 4822 116 52264 27kΩ 0,5W 2844 4822 122 33195 100pF 2846 4822 122 33197 3638 4822 116 52264 27kΩ 0,5W 2848 4822 122 33197 3639 4822 116 83864 10kΩ 0,5W 2850 4822 126 12882 100nF 3640 4822 116 83864...
  • Page 33 ELECTRICAL PARTSLIST RESISTORS DIODES ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3853 4822 116 52244 15kΩ 0,5W 6252 4822 130 31878 1N4003G 3854 4822 116 52243 1,5kΩ 0,16W 6253 4822 130 31878 1N4003G 3855 4822 116 52271 33kΩ 0,16W 6256 4822 130 30621 1N4148 3856 4822 116 52303 8,2kΩ...

This manual is also suitable for:

Az1010

Table of Contents